[Federal Register Volume 88, Number 13 (Friday, January 20, 2023)]
[Rules and Regulations]
[Pages 3629-3631]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 2023-01113]



 ========================================================================
 Rules and Regulations
                                                 Federal Register
 ________________________________________________________________________
 
 This section of the FEDERAL REGISTER contains regulatory documents 
 having general applicability and legal effect, most of which are keyed 
 to and codified in the Code of Federal Regulations, which is published 
 under 50 titles pursuant to 44 U.S.C. 1510.
 
 The Code of Federal Regulations is sold by the Superintendent of Documents. 
 
 ========================================================================
 

  Federal Register / Vol. 88, No. 13 / Friday, January 20, 2023 / Rules 
and Regulations  

[[Page 3629]]



DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. FAA-2023-0021; Project Identifier MCAI-2022-01618-E; 
Amendment 39-22306; AD 2023-01-12]
RIN 2120-AA64


Airworthiness Directives; Safran Helicopter Engines, S.A. (Type 
Certificate Previously Held by Turbomeca, S.A.) Turboshaft Engines

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Final rule; request for comments.

-----------------------------------------------------------------------

SUMMARY: The FAA is adopting a new airworthiness directive (AD) for all 
Safran Helicopter Engines, S.A. (Safran) Arriel 1C, Arriel 1C1, and 
Arriel 1C2 model turboshaft engines. This AD was prompted by reports of 
false engine fire warnings. This AD requires replacing the affected 
fire detectors, as specified in a European Union Aviation Safety Agency 
(EASA) AD, which is incorporated by reference. This AD also prohibits 
the installation of affected fire detectors. The FAA is issuing this AD 
to address the unsafe condition on these products.

DATES: This AD is effective February 6, 2023.
    The Director of the Federal Register approved the incorporation by 
reference of a certain publication listed in this AD as of February 6, 
2023.
    The FAA must receive comments on this AD by March 6, 2023.

ADDRESSES: You may send comments, using the procedures found in 14 CFR 
11.43 and 11.45, by any of the following methods:
     Federal eRulemaking Portal: Go to regulations.gov. Follow 
the instructions for submitting comments.
     Fax: (202) 493-2251.
     Mail: U.S. Department of Transportation, Docket 
Operations, M-30, West Building Ground Floor, Room W12-140, 1200 New 
Jersey Avenue SE, Washington, DC 20590.
     Hand Delivery: Deliver to Mail address above between 9 
a.m. and 5 p.m., Monday through Friday, except Federal holidays.
    AD Docket: You may examine the AD docket at regulations.gov under 
Docket No. FAA-2023-0021; or in person at Docket Operations between 9 
a.m. and 5 p.m., Monday through Friday, except Federal holidays. The AD 
docket contains this final rule, the mandatory continuing airworthiness 
information (MCAI), any comments received, and other information. The 
street address for Docket Operations is listed above.
    Material Incorporated by Reference:
     For EASA material incorporated by reference in this AD, 
contact EASA, Konrad-Adenauer-Ufer 3, 50668 Cologne, Germany; phone: 
+49 221 8999 000; email: [email protected]; website: easa.europa.eu. 
You may find this material on the EASA website at ad.easa.europa.eu.
     You may view this service information at the FAA, 
Airworthiness Products Section, Operational Safety Branch, 1200 
District Avenue, Burlington, MA 01803. For information on the 
availability of this material at the FAA, call (817) 222-5110. It is 
also available at regulations.gov under Docket No. FAA-2023-0021.

FOR FURTHER INFORMATION CONTACT: Kevin Clark, Aviation Safety Engineer, 
ECO Branch, FAA, 1200 District Avenue, Burlington, MA 01803; phone: 
(781) 238-7088; email: [email protected].

SUPPLEMENTARY INFORMATION:

Comments Invited

    The FAA invites you to send any written data, views, or arguments 
about this final rule. Send your comments to an address listed under 
ADDRESSES. Include ``Docket No. FAA-2023-0021; Project Identifier MCAI-
2022-01618-E'' at the beginning of your comments. The most helpful 
comments reference a specific portion of the final rule, explain the 
reason for any recommended change, and include supporting data. The FAA 
will consider all comments received by the closing date and may amend 
this final rule because of those comments.
    Except for Confidential Business Information (CBI) as described in 
the following paragraph, and other information as described in 14 CFR 
11.35, the FAA will post all comments received, without change, to 
regulations.gov, including any personal information you provide. The 
agency will also post a report summarizing each substantive verbal 
contact received about this final rule.

Confidential Business Information

    CBI is commercial or financial information that is both customarily 
and actually treated as private by its owner. Under the Freedom of 
Information Act (FOIA) (5 U.S.C. 552), CBI is exempt from public 
disclosure. If your comments responsive to this AD contain commercial 
or financial information that is customarily treated as private, that 
you actually treat as private, and that is relevant or responsive to 
this AD, it is important that you clearly designate the submitted 
comments as CBI. Please mark each page of your submission containing 
CBI as ``PROPIN.'' The FAA will treat such marked submissions as 
confidential under the FOIA, and they will not be placed in the public 
docket of this AD. Submissions containing CBI should be sent to Kevin 
Clark, Aviation Safety Engineer, ECO Branch, FAA, 1200 District Avenue, 
Burlington, MA 01803. Any commentary that the FAA receives which is not 
specifically designated as CBI will be placed in the public docket for 
this rulemaking.

Background

    EASA, which is the Technical Agent for the Member States of the 
European Union, has issued EASA AD 2022-0256, dated December 19, 2022 
(EASA AD 2022-0256) (also referred to as the MCAI), to correct an 
unsafe condition on all Safran Arriel 1C, Arriel 1C1, and Arriel 1C2 
model turboshaft engines. The MCAI states that there were reports of 
false engine fire warnings. The subsequent investigation results 
identified a manufacturing non-compliance on the fire detectors, which 
caused a shift of the detection threshold towards temperature values 
that are lower than specified, potentially leading to a false engine 
fire warning. When two engines on a helicopter are fitted with an 
affected part, an engine fire warning could occur on both engines 
during the same flight. This condition, if not addressed, could lead to 
commanded in-flight engine shut-down, possibly

[[Page 3630]]

resulting in damage to the helicopter and reduced control of the 
helicopter.
    The FAA is issuing this AD to address the unsafe condition on these 
products.
    You may examine the MCAI in the AD docket at regulations.gov under 
Docket No. FAA-2023-0021.

Related Service Information Under 1 CFR Part 51

    The FAA reviewed EASA AD 2022-0256, which specifies procedures for 
replacing affected fire detectors. This material is reasonably 
available because the interested parties have access to it through 
their normal course of business or by the means identified in 
ADDRESSES.

FAA's Determination

    These products have been approved by the aviation authority of 
another country and are approved for operation in the United States. 
Pursuant to the FAA's bilateral agreement with this State of Design 
Authority, it has notified the FAA of the unsafe condition described in 
the MCAI described above. The FAA is issuing this AD after determining 
that the unsafe condition described previously is likely to exist or 
develop on other products of these same type designs.

AD Requirements

    This AD requires accomplishing the actions specified in EASA AD 
2022-0256, except for any differences identified as exceptions in the 
regulatory text of this AD. This AD also prohibits the installation of 
affected fire detectors.

Explanation of Required Compliance Information

    In the FAA's ongoing efforts to improve the efficiency of the AD 
process, the FAA developed a process to use some civil aviation 
authority (CAA) ADs as the primary source of information for compliance 
with requirements for corresponding FAA ADs. The FAA has been 
coordinating this process with manufacturers and CAAs. As a result, 
EASA AD 2022-0256 is incorporated by reference in this AD. This AD 
requires compliance with EASA AD 2022-0256 in its entirety through that 
incorporation, except for any differences identified as exceptions in 
the regulatory text of this AD. Using common terms that are the same as 
the heading of a particular section in EASA AD 2022-0256 does not mean 
that operators need comply only with that section. For example, where 
the AD requirement refers to ``all required actions and compliance 
times,'' compliance with this AD requirement is not limited to the 
section titled ``Required Action(s) and Compliance Time(s)'' in EASA AD 
2022-0256. Service information required by EASA AD 2022-0256 for 
compliance will be available at regulations.gov under Docket No. FAA-
2023-0021 after this AD is published.

Justification for Immediate Adoption and Determination of the Effective 
Date

    Section 553(b)(3)(B) of the Administrative Procedure Act (APA) (5 
U.S.C. 551 et seq.) authorizes agencies to dispense with notice and 
comment procedures for rules when the agency, for ``good cause,'' finds 
that those procedures are ``impracticable, unnecessary, or contrary to 
the public interest.'' Under this section, an agency, upon finding good 
cause, may issue a final rule without providing notice and seeking 
comment prior to issuance. Further, section 553(d) of the APA 
authorizes agencies to make rules effective in less than thirty days, 
upon a finding of good cause.
    An unsafe condition exists that requires the immediate adoption of 
this AD without providing an opportunity for public comments prior to 
adoption. The FAA has found that the risk to the flying public 
justifies foregoing notice and comment prior to adoption of this rule 
because fire detectors that do not conform to the type design could 
lead to false engine fire warnings. Safran was informed of three 
occurrences of illumination of the engine fire alarm without confirmed 
fire (untimely illumination) on airframes equipped with affected fire 
detectors. False engine fire warnings are an unsafe condition requiring 
urgent corrective action because, if a helicopter is equipped with two 
engines with an affected fire detector installed, an engine fire 
warning could occur on both engines during the same flight. This unsafe 
condition, if not addressed, could lead to commanded in-flight engine 
shut-down, possibly resulting in damage to the helicopter and reduced 
control of the helicopter. Replacement of the fire detectors must be 
accomplished within 30 flight hours or 60 days from the effective date 
of this AD, whichever occurs first. Accordingly, notice and opportunity 
for prior public comment are impracticable and contrary to the public 
interest pursuant to 5 U.S.C. 553(b)(3)(B).
    In addition, the FAA finds that good cause exists pursuant to 5 
U.S.C. 553(d) for making this amendment effective in less than 30 days, 
for the same reasons the FAA found good cause to forego notice and 
comment.

Regulatory Flexibility Act (RFA)

    The requirements of the RFA do not apply when an agency finds good 
cause pursuant to 5 U.S.C. 553 to adopt a rule without prior notice and 
comment. Because the FAA has determined that it has good cause to adopt 
this rule without prior notice and comment, RFA analysis is not 
required.

Costs of Compliance

    The FAA estimates that this AD affects 30 engines installed on 
helicopters of U.S. registry. The FAA estimates the following costs to 
comply with this AD:

                                                 Estimated Costs
----------------------------------------------------------------------------------------------------------------
                                                                                     Cost per      Cost on U.S.
                Action                         Labor cost           Parts cost        product        operators
----------------------------------------------------------------------------------------------------------------
Replace fire detectors................  1 work-hour x $85 per             $1,800          $1,885         $56,550
                                         hour = $85.
----------------------------------------------------------------------------------------------------------------

Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to 
issue rules on aviation safety. Subtitle I, section 106, describes the 
authority of the FAA Administrator. Subtitle VII: Aviation Programs 
describes in more detail the scope of the Agency's authority.
    The FAA is issuing this rulemaking under the authority described in 
Subtitle VII, Part A, Subpart III, Section 44701: General requirements. 
Under that section, Congress charges the FAA with promoting safe flight 
of civil aircraft in air commerce by prescribing regulations for 
practices, methods, and procedures the Administrator finds necessary 
for safety in air commerce. This regulation is within the scope of that 
authority because it addresses an unsafe condition that is likely to 
exist or

[[Page 3631]]

develop on products identified in this rulemaking action.

Regulatory Findings

    This AD will not have federalism implications under Executive Order 
13132. This AD will not have a substantial direct effect on the States, 
on the relationship between the national government and the States, or 
on the distribution of power and responsibilities among the various 
levels of government.
    For the reasons discussed above, I certify that this AD:
    (1) Is not a ``significant regulatory action'' under Executive 
Order 12866, and
    (2) Will not affect intrastate aviation in Alaska.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

The Amendment

    Accordingly, under the authority delegated to me by the 
Administrator, the FAA amends 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0
1. The authority citation for part 39 continues to read as follows:

    Authority:  49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13  [Amended]

0
2. The FAA amends Sec.  39.13 by adding the following new airworthiness 
directive:

2023-01-12 Safran Helicopter Engines, S.A. (Type Certificate 
Previously Held by Turbomeca, S.A.): Amendment 39-22306; Docket No. 
FAA-2023-0021; Project Identifier MCAI-2022-01618-E.

(a) Effective Date

    This airworthiness directive (AD) is effective February 6, 2023.

(b) Affected ADs

    None.

(c) Applicability

    This AD applies to all Safran Helicopter Engines, S.A. (Type 
Certificate previously held by Turbomeca, S.A.) Arriel 1C, Arriel 
1C1, and Arriel 1C2 model turboshaft engines.

(d) Subject

    Joint Aircraft System Component (JASC) Code 7200, Engine 
(Turbine/Turboprop).

(e) Unsafe Condition

    This AD was prompted by reports of false engine fire warnings. 
The FAA is issuing this AD to prevent false engine fire warnings. 
The unsafe condition, if not addressed, could lead to commanded in-
flight engine shut-down, possibly resulting in damage to the 
helicopter and reduced control of the helicopter.

(f) Compliance

    Comply with this AD within the compliance times specified, 
unless already done.

(g) Required Actions

    Except as specified in paragraphs (h) and (i) of this AD: 
Perform all required actions within the compliance times specified 
in, and in accordance with European Union Aviation Safety Agency 
(EASA) AD 2022-0256, dated December 19, 2022 (EASA AD 2022-0256).

(h) Exceptions to EASA AD 2022-0256

    (1) Where EASA AD 2022-0256 requires compliance from its 
effective date, this AD requires using the effective date of this 
AD.
    (2) This AD does not adopt the ``Remarks'' section of EASA AD 
2022-0256.
    (3) Although the service information referenced in EASA AD 2022-
0256 specifies to discard any removed fire detectors, this AD 
requires removing those parts from service.

(i) No Reporting Requirement

    Although the service information referenced in EASA AD 2022-0256 
specifies to submit certain information to the manufacturer, this AD 
does not include that requirement.

(j) Alternative Methods of Compliance (AMOCs)

    (1) The Manager, ECO Branch, FAA, has the authority to approve 
AMOCs for this AD, if requested using the procedures found in 14 CFR 
39.19. In accordance with 14 CFR 39.19, send your request to your 
principal inspector or local Flight Standards District Office, as 
appropriate. If sending information directly to the manager of the 
certification office, send it to the attention of the person 
identified in paragraph (k) of this AD and email to: [email protected].
    (2) Before using any approved AMOC, notify your appropriate 
principal inspector, or lacking a principal inspector, the manager 
of the local flight standards district office/certificate holding 
district office.

(k) Additional Information

    For more information about this AD, contact Kevin Clark, 
Aviation Safety Engineer, ECO Branch, FAA, 1200 District Avenue, 
Burlington, MA 01803; phone: (781) 238-7088; email: 
[email protected].

(l) Material Incorporated by Reference

    (1) The Director of the Federal Register approved the 
incorporation by reference of the service information listed in this 
paragraph under 5 U.S.C. 552(a) and 1 CFR part 51.
    (2) You must use this service information as applicable to do 
the actions required by this AD, unless the AD specifies otherwise.
    (i) European Union Aviation Safety Agency (EASA) AD 2022-0256, 
dated December 19, 2022.
    (ii) [Reserved]
    (3) For EASA AD 2022-0256, contact EASA, Konrad-Adenauer-Ufer 3, 
50668 Cologne, Germany; phone: +49 221 8999 000; email: 
[email protected]. You may find this material on the EASA website 
at ad.easa.europa.eu.
    (4) You may view this service information at the FAA, 
Airworthiness Products Section, Operational Safety Branch, 1200 
District Avenue, Burlington, MA 01803. For information on the 
availability of this material at the FAA, call (817) 222-5110.
    (5) You may view this service information that is incorporated 
by reference at the National Archives and Records Administration 
(NARA). For information on the availability of this material at 
NARA, email: [email protected], or go to: www.archives.gov/federal-register/cfr/ibr-locations.html.

    Issued on January 13, 2023.
Gaetano A. Sciortino,
Acting Director, Compliance & Airworthiness Division, Aircraft 
Certification Service.
[FR Doc. 2023-01113 Filed 1-18-23; 11:15 am]
BILLING CODE 4910-13-P


