[Federal Register Volume 85, Number 40 (Friday, February 28, 2020)]
[Rules and Regulations]
[Pages 11836-11841]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 2020-03475]


=======================================================================
-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 25

[Docket No. FAA-2019-0330; Special Conditions No. 25-761-SC]


Special Conditions: The Boeing Company Model 777-9 Series; 
Overhead Flight Attendant Rest Compartment

AGENCY: Federal Aviation Administration (FAA), DOT.

ACTION: Final special conditions.

-----------------------------------------------------------------------

SUMMARY: These special conditions are issued for the Boeing Company 
(Boeing) Model 777-9 series airplane. This airplane will have a novel 
or unusual design feature when compared to the state of technology 
envisioned in the airworthiness standards for transport category 
airplanes. This design feature is associated with the installation of 
an overhead flight attendant rest (OFAR) compartment. The applicable 
airworthiness regulations do not contain adequate or appropriate safety 
standards for this design feature. These special conditions contain the 
additional safety standards that the Administrator considers necessary 
to establish a level of safety equivalent to that established by the 
existing airworthiness standards.

DATES: Effective March 30, 2020.

FOR FURTHER INFORMATION CONTACT: Shannon Lennon, Airframe and Cabin 
Safety Section, AIR-675, Transport Standards Branch, Policy and 
Innovation Division, Aircraft Certification Service, Federal Aviation 
Administration, 2200 South 216th Street, Des Moines, Washington 98198; 
telephone and fax 206-231-3209; email shannon.lennon@faa.gov.

SUPPLEMENTARY INFORMATION: 

Background

    On April 24, 2018, The Boeing Company applied for an amendment to 
Type Certificate No. T00001SE to include the new Model 777-9 series 
airplane. The Boeing Model 777-9 series airplane, which is a derivative 
of the 777-300ER currently approved under Type Certificate No. 
T00001SE, is a twin-engine, transport category airplane with seating 
for up to 495 passengers depending upon airplane configuration, and a 
maximum takeoff weight of approximately 775,000 lbs.

Type Certification Basis

    Under the provisions of title 14, Code of Federal Regulations (14 
CFR) 21.101, Boeing must show that the Model 777-9 series airplane 
continues to meet the applicable provisions of part 25, as amended by 
amendments 25-1 through 25-139, and parts 26, 34, and 36, and the 
regulations listed in Type Certificate No. T00001SE or the applicable 
regulations in effect on the date of application for the change, except 
for earlier amendments as agreed upon by the FAA.
    If the Administrator finds that the applicable airworthiness 
regulations (e.g., 14 CFR part 25) do not contain adequate or 
appropriate safety standards for the Boeing Model 777-9 series airplane 
because of a novel or unusual design feature, special conditions are 
prescribed under the provisions of Sec.  21.16.
    Special conditions are initially applicable to the model for which 
they are issued. Should the type certificate for that model be amended 
later to include any other model that incorporates the same novel or 
unusual design feature, these special conditions would also apply to 
the other model under Sec.  21.101.
    In addition to the applicable airworthiness regulations and special 
conditions, the Boeing Model 777-9

[[Page 11837]]

series airplane must comply with the fuel vent and exhaust emission 
requirements of 14 CFR part 34 and the noise certification requirements 
of 14 CFR part 36.
    The FAA issues special conditions, as defined in 14 CFR 11.19, in 
accordance with Sec.  11.38, and they become part of the type 
certification basis under Sec.  21.101.

Novel or Unusual Design Features

    The Boeing Model 777-9 series airplane will incorporate the 
following novel or unusual design features:
    This airplane will have an installation of an OFAR compartment. The 
OFAR compartment of the Boeing Model 777-9 series airplane is novel and 
unusual due to its design, location, and use on the airplane. It is 
located in the overhead area of the passenger compartment and 
crewmembers may occupy this compartment for crew rest purposes during 
flight.

Discussion

    Boeing has previously installed certified OFAR compartments on 
Boeing Model 777 series airplanes in varied locations, such as the main 
passenger seating area, the overhead space above the main passenger 
cabin seating area, and below the passenger cabin seating area within 
the cargo compartment. In each case, the Administrator determined that 
the applicable regulations did not provide all of the necessary 
requirements because each installation had novel or unusual features by 
virtue of its design, location, and use on the airplane.
    When the Administrator finds that the applicable airworthiness 
regulations do not contain adequate or appropriate safety standards 
because of a novel or unusual design feature, special conditions are 
prescribed under the provisions of Sec.  21.16. The special conditions 
contain safety standards that the Administrator considers necessary to 
establish a level of safety equivalent to that established by the 
existing airworthiness standards.
    For the Boeing Model 777-9 series airplane, the OFAR compartment is 
located in the overhead space, above the main passenger cabin seating 
area, adjacent to Door 5. The OFAR compartment will contain six, eight, 
or ten private berths depending upon customer configuration. 
Additionally, only crewmembers who have been trained in OFAR procedures 
will occupy this compartment, and do so only in flight, not during 
taxi, takeoff, or landing. Crewmembers will access the OFAR compartment 
from the main deck by stairs through a vestibule. In addition, a 
secondary evacuation route, which opens directly into the main 
passenger seating area, will be available as an alternate route for 
evacuating occupants of the compartment. The compartment will provide a 
smoke detection system, an oxygen system, and occupant amenities.
    The FAA's design standards, including part Sec.  25.853 (a), (e), 
and (h), do not adequately address the Boeing Model 777-9 series 
airplane OFAR compartment due to its design, location, and use on the 
airplane. This compartment is novel in that it is located in the 
overhead area of the passenger compartment and crewmembers may occupy 
this compartment for crew rest purposes during flight. Due to the novel 
or unusual features associated with the installation of this 
compartment, the FAA finds that special conditions are necessary to 
provide a level of safety equal to that established by the 
airworthiness regulations.
    Boeing originally requested that Special Conditions No. 25-230-SC 
(68 FR 17513, April 9, 2003) for the OFAR compartment on the Model 777 
airplane be made applicable to the Boeing Model 777-9 series airplane. 
However, after the issuance of Special Conditions No. 25-230-SC, the 
FAA issued Special Conditions No. 25-419-SC (76 FR 10482, February 25, 
2011), for OFAR compartments allowed to be occupied during flight on 
Boeing Model 787 series airplanes, with changes to better address 
oxygen systems and fire suppression. Those special conditions reflected 
the methodology necessary to provide an equivalent level of safety for 
remote OFAR compartments, therefore new special conditions were 
proposed for these design features on Boeing Model 777-9 series 
airplanes.
    The special conditions contain the additional safety standards that 
the Administrator considers necessary to establish a level of safety 
equivalent to that established by the existing airworthiness standards.

Discussion of Comments

    Notice of Proposed Special Conditions No. 25-19-05-SC for the 
Boeing Model 777-9 series airplane was published in the Federal 
Register on August 19, 2019 (84 FR 42842). The FAA received one 
comment, from Boeing.
    Boeing requested that the FAA specify that analyses could be used 
in lieu of flight tests to show compliance with special conditions 
numbers 10, 11, 12e, and 18b. The FAA does not agree with the requested 
change. Flight testing is necessary to establish in-flight ventilation 
conditions, in order to assess the performance of smoke detectors, the 
penetration of smoke from the OFAR to the cabin, and the capability of 
the suppression system. Also, the current language has been used on 
similar special conditions, and these special conditions permitted the 
use of the similarity analysis that Boeing has requested. The text of 
this special condition (i.e., the applicant must conduct flight tests 
to show compliance with this requirement) does not eliminate the use of 
similarity analysis to justify validity and applicability of previously 
generated flight test data in lieu of conducting a new flight test. 
Applicants may propose the use of flight test certification data from a 
previously certificated design. The FAA's acceptance of the use of that 
data to determine compliance will depend upon the comparison between 
the previously certificated design and the proposed design in order to 
show that the previously generated flight test data is valid and 
applicable to represent the performance of proposed design and will 
show compliance to the special condition. Insertion of the term, 
analysis, in the conditions is unnecessary based on previous acceptance 
of the similarity approach described above. Furthermore, the addition 
of the term, analysis, changes the meaning of the conditions, which may 
subsequently result in confusion, and/or use of unintended compliance 
approaches. Therefore, the FAA finds that no change to the special 
condition is warranted.

Applicability

    As discussed above, these special conditions are applicable to the 
Boeing Model 777-9 series airplane. Should Boeing apply at a later date 
for a change to the type certificate to include another model 
incorporating the same novel or unusual design feature, these special 
conditions would apply to that model as well.

Conclusion

    This action affects only certain novel or unusual design features 
on one model series of airplanes. It is not a rule of general 
applicability.

List of Subjects in 14 CFR Part 25

    Aircraft, Aviation safety, Reporting and recordkeeping 
requirements.

Authority Citation

    The authority citation for these special conditions is as follows:

    Authority:  49 U.S.C. 106(f), 106(g), 40113, 44701, 44702, 
44704.

[[Page 11838]]

The Special Conditions

    Accordingly, pursuant to the authority delegated to me by the 
Administrator, the following special conditions are issued as part of 
the type certification basis for the Boeing Model 777-9 series 
airplane.

Overhead Flight Attendant Rest (OFAR) Special Conditions

    1. OFAR Compartment Occupancy. Occupancy of the OFAR compartment is 
limited to the total number of installed bunks and seats in each 
compartment. An approved seat or berth--able to withstand the maximum 
flight loads when occupied for each occupant permitted in the OFAR 
compartment--must be available. Maximum occupancy in the OFAR 
compartment is six, eight, or ten crewmembers during flight depending 
upon customer configuration.
    a. Appropriate placards must be located inside and outside each 
entrance to the OFAR compartment to indicate:
    (1) The maximum number of occupants allowed during flight.
    (2) Occupancy is restricted to crewmembers who are trained in the 
evacuation procedures for the OFAR compartment.
    (3) Occupancy is prohibited during taxi, take-off, and landing.
    (4) Smoking is prohibited in the OFAR compartment.
    (5) That stowage in the OFAR compartment must be limited to 
emergency equipment, airplane-supplied equipment (e.g., bedding), and 
crew personal luggage; the stowage of cargo and passenger baggage is 
not allowed.
    b. At least one ashtray must be located on both the inside and the 
outside of any entrance to the OFAR compartment.
    c. A limitation in the airplane flight manual, or other means, must 
be established to restrict occupancy to crewmembers that the pilot in 
command has determined to be trained in the emergency procedures for 
the OFAR compartment.
    d. A limitation in the airplane flight manual, or other means, must 
be established to restrict occupancy to crewmembers that have received 
training to be able to rapidly use the evacuation routes of the OFAR 
compartment.
    e. A means must be in place for any door installed between the OFAR 
compartment and the passenger cabin to be quickly opened from inside 
the compartment, even when crowding occurs at each side of the door.
    f. For all OFAR compartment doors installed, a means must be in 
place that precludes anyone from being trapped inside the OFAR 
compartment. If a manufacturer or operator installs a locking mechanism 
on a door, it must be capable of being unlocked from the outside 
without the aid of special tools. The lock must not prevent opening 
from the inside of the OFAR compartment at any time.
    g. The means of opening doors and hatches to the OFAR compartment 
must be simple and obvious. Crewmembers must be able to close OFAR 
compartment doors and hatches from the main passenger cabin. Doors or 
hatches that separate the OFAR compartment from the main deck must not 
adversely affect evacuation of occupants on the main deck, for example, 
by slowing evacuation by encroaching into aisles, or causing injury to 
those occupants during opening of doors, or while doors are opened.
    2. Emergency Evacuation Routes. At least two emergency evacuation 
routes must be available for occupants of the OFAR compartment to 
evacuate rapidly to the main cabin. OFAR compartment doors must be able 
to close these evacuation routes from the main passenger cabin after 
evacuation. In addition-
    a. These routes must be located with sufficient separation within 
the OFAR compartment to minimize the possibility of an event either 
inside or outside of the OFAR compartment rendering both routes 
inoperative.
    b. The routes must be designed to minimize the possibility of 
blockage, which might result from fire, mechanical or structural 
failure, or persons standing below or against the OFAR compartment 
outlets.
    c. One of the two OFAR evacuation routes must not be located where 
egress from the OFAR compartment may be impeded during times when 
normal movement or occupancy is allowed or evacuation by passengers 
occurs (for example, the main aisle, cross aisle, or galley complex). 
If an evacuation route is in an area where normal movement of 
passengers occurs, it must be demonstrated that passengers would not 
impede egress to the main deck.
    d. If low headroom is at or near the evacuation route, provisions 
must be made to prevent or to protect occupants of the OFAR compartment 
from head injury.
    e. Use of evacuation routes must not depend on any powered device.
    f. If an OFAR compartment outlet is over an area of passenger 
seats, a maximum of five passengers may be displaced from their seats 
temporarily during the process of evacuating an incapacitated 
person(s).
    g. If an evacuation procedure involves the evacuee stepping on 
seats, the seats must not be damaged to the extent that they would not 
be acceptable for occupancy during an emergency landing.
    h. OFAR compartment emergency evacuation procedures--including 
procedures for emergency evacuation of an incapacitated occupant from 
the OFAR compartment--must be established by the applicant. The 
applicant must transmit all of these procedures to each owner and 
operator for incorporation into its training programs and appropriate 
operational manuals.
    i. A limitation must be included in the airplane flight manual, or 
other suitable means, to require that crewmembers are trained in the 
use of the OFAR compartment evacuation routes.
    3. Evacuation of Incapacitated Person. A means must be available 
for evacuating an incapacitated person (representative of a 95th 
percentile male) from the OFAR compartment to the passenger cabin 
floor.
    Exit Signs and Placards. The following exit signs and placards, 
meeting the following criteria, must be placed in the OFAR compartment:
    a. At least one exit sign, located near each OFAR compartment 
outlet, meeting the emergency lighting requirements of Sec.  
25.812(b)(1)(i).
    (1) One allowable exception to the minimum area requirement of 
Sec.  25.812(b)(1)(i) is an exit sign having a reduced background area 
of no less than 5.3 square inches that is installed where the material 
surrounding the exit sign is light in color (such as white, cream, or 
light beige).
    (2) If the material surrounding the exit sign is not light in 
color, a sign with a minimum of a one-inch-wide background border 
around the letters is acceptable.
    (3) Another allowable exception requirement of Sec.  
25.812(b)(1)(i) in the OFAR compartment is a sign with a symbol that 
the FAA has determined to be equivalent for use as an exit sign that 
meets Sec.  25.811(d).
    b. An appropriate placard for general access should be located 
conspicuously on or near each OFAR compartment door or hatch that 
defines the location and the operating instructions for access to and 
operation of the outlet door or hatch.
    c. Placards must be readable from a distance of 30 inches under 
emergency lighting conditions.

[[Page 11839]]

    d. The door handles, hatch handles, and operating-instruction 
placards required by Special Condition 4(b) of these special conditions 
must be illuminated to at least 160 micro lamberts under emergency 
lighting conditions.
    5. Emergency Illumination. A means must be available, in the event 
of failure of the aircraft's main power system, and of the normal OFAR 
compartment lighting system, for emergency illumination to be 
automatically provided for the OFAR compartment.
    a. This emergency illumination must be powered independent of the 
main lighting system.
    b. The sources of general cabin illumination of the OFAR may be 
common to both the emergency and the main lighting systems, if the 
power supply to the emergency lighting system is independent of the 
power supply to the main lighting system.
    c. The emergency illumination level must be sufficient to allow 
occupants of the OFAR compartment to locate and move to the main 
passenger cabin floor by means of each evacuation route.
    d. The emergency illumination level must be sufficient, with the 
privacy curtains in the closed position, for each occupant of the OFAR 
compartment to locate a deployed oxygen mask required by Special 
Condition 13 of these special conditions.
    6. Two-Way Voice Communications. A means must be available for two-
way voice communications between crewmembers on the flight deck and 
occupants of the OFAR compartment.
    a. Two-way communications must also be available between occupants 
of the OFAR compartment and each flight attendant station in the 
passenger cabin that is required per Sec.  25.1423(g) to have a 
microphone for the public address system.
    b. The public address system must be able to communicate the 
relevant safety information to the crewmembers in the OFAR compartment 
(for example, fire in flight, aircraft depressurization, and 
preparation of the compartment for landing).
    7. Emergency Alarm System. A means must be available for manual 
activation of an aural emergency alarm system, audible during normal 
and emergency conditions that enable crewmembers on the flight deck and 
at each pair of the required floor-level emergency exits to alert 
occupants of the OFAR compartment of an emergency. The use of a public 
address or crew interphone system is acceptable, provided an adequate 
means of differentiating between normal and emergency communications is 
incorporated. The system must be powered in flight and after the 
shutdown or failure of all engines and auxiliary power units for a 
period of at least ten minutes.
    8. Seatbelt Fasten Signal. A signal, readily detectable by seated 
or standing occupants of the OFAR compartment, must be in place to 
indicate when seat belts should be fastened.
    a. If the OFAR compartment has no seats, at least one means must be 
provided to cover anticipated turbulence (e.g., sufficient handholds).
    b. Seatbelt-type restraints must be provided for berths and must be 
compatible for the sleeping position during cruise conditions.
    c. A placard on each berth must require that these restraints be 
fastened when occupied.
    d. If compliance with any of the other requirements of these 
special conditions predicates a specific head position, a placard must 
identify that head position.
    9. Protective Breathing Equipment (PBE). In lieu of the 
requirements specified in Sec.  25.1439(a) pertaining to PBE in 
isolated compartments, and to provide a level of safety equivalent that 
is provided to occupants of an isolated galley, the following equipment 
must be provided in the OFAR compartment:
    a. Two PBE devices suitable for firefighting, or one PBE for each 
hand-held fire extinguisher, whichever is greater. All PBE devices must 
be approved to Technical Standard Order (TSO)-C116 or equivalent.
    b. At least one approved, hand-held fire extinguisher appropriate 
for the kinds of fires likely to occur.
    c. One flashlight.

    Note: Additional PBE devices and fire extinguishers in specific 
locations, beyond the minimum numbers prescribed in Special 
Condition 9, may be required as a result of the egress analysis 
accomplished to satisfy Special Condition 2(a) of these special 
conditions.

    10. Smoke and fire detection system. Smoke and fire detection 
system(s) must be provided that monitor each occupiable area within the 
OFAR compartment, including those areas partitioned by curtains or 
doors. The applicant must conduct flight tests to show compliance with 
this requirement. Each smoke or fire detection system(s) must provide:
    a. A visual indication to the flight deck within one minute after 
the start of a fire.
    b. An aural warning in the OFAR compartment.
    c. An aural or visual warning in the main passenger cabin. This 
warning must be readily detectable by a flight attendant, taking into 
consideration the locations of flight attendants throughout the main 
passenger compartment during various phases of flight.
    11. Built-in fire suppression system. The OFAR compartment must be 
designed such that fires within the compartment can be controlled 
without a crewmember having to enter the compartment (i.e., built-in 
fire suppression system), or the design of the access provisions must 
allow crewmembers equipped for firefighting to have unrestricted access 
to the compartment. The time for a crewmember on the main deck to react 
to the fire alarm, to don the firefighting equipment, and to gain 
access must not exceed the time for the compartment to become smoke-
filled, making it difficult to locate the fire source. The acceptable 
duration that the suppression capability of a built-in fire suppression 
system can be maintained must be verified by certification flight-
testing.
    12. Hazardous Smoke and Extinguishing Agent. The applicant must 
provide a means to prevent hazardous quantities of smoke or 
extinguishing agent originating in the OFAR compartment from entering 
the flight deck, passenger cabin, or any other occupiable compartment.
    a. Small quantities of smoke may penetrate from the OFAR 
compartment into other occupied areas during the one-minute smoke 
detection time.
    b. Firefighting procedures must ensure that crewmembers close all 
doors and hatches at the OFAR compartment outlets after evacuation of 
the compartment and during firefighting to minimize smoke and 
extinguishing agent entering other occupiable compartments.
    c. Hazardous quantities of smoke may not enter any occupied 
compartment while a crewmember accesses an OFAR compartment to manually 
fight a fire there. The amount of smoke entrained by a crewmember 
exiting the OFAR compartment is not considered a hazardous amount.
    d. Smoke entering any occupiable compartment, when access to the 
OFAR compartment is open for evacuation, must dissipate within five 
minutes after the access to the OFAR compartment is closed.
    e. The applicant must conduct flight tests to show compliance with 
this requirement.
    13. Supplemental Oxygen System. A supplemental oxygen system within 
the OFAR compartment that supplies oxygen in the event of decompression 
must provide the following:
    a. At least one oxygen mask for each seat and berth in the OFAR 
compartment.

[[Page 11840]]

    b. If a destination area, such as a changing area, is provided in 
the OFAR compartment, an oxygen mask must be readily available for each 
occupant who can reasonably be expected to be in the destination area. 
The maximum number of required oxygen masks within the destination area 
is limited to the placarded maximum occupancy of the OFAR compartment.
    c. An oxygen mask must be readily accessible to each occupant who 
can reasonably be expected to be moving from the main cabin into the 
OFAR compartment, moving around within the OFAR compartment, or moving 
from the OFAR compartment to the main cabin.
    d. The supplemental oxygen system must provide an aural and visual 
alert to warn occupants of the OFAR compartment to don oxygen masks in 
the event of decompression.
    (1) The aural and visual alerts must activate concurrently with 
deployment of the oxygen masks in the passenger cabin.
    (2) To compensate for sleeping occupants, the aural alert must be 
heard in each section of the OFAR compartment and must sound 
continuously for a minimum of five minutes or until a reset switch 
within the OFAR compartment is activated.
    (3) A visual alert that informs occupants that they must don an 
oxygen mask must be visible in each section.
    e. A means must be in place by which oxygen masks in the OFAR 
compartment can be manually deployed from the flight deck.
    f. The applicant must establish approved procedures for OFAR 
occupants in the event of decompression. These procedures must be 
provided to the operator for incorporation into its training programs 
and appropriate operational manuals.
    g. The supplemental oxygen system for the OFAR compartment must 
meet the same 14 CFR part 25 regulations for the supplemental oxygen 
system for the passenger cabin occupants, except for the 10 percent 
additional masks requirement of 14 CFR 25.1447(c)(1).
    h. The illumination level of the normal OFAR compartment lighting 
system must automatically be sufficient for each occupant of the 
compartment to locate a deployed oxygen mask.
    14. Divided OFAR Compartments. The following requirements apply to 
OFAR compartments that are divided into more than one section by the 
installation of curtains or partitions:
    a. A placard is required adjacent to each curtain that visually 
divides or separates the OFAR compartment into smaller sections. The 
placard must require that the curtain(s) remains open when that section 
is unoccupied. The vestibule section adjacent to the stairway is not 
considered a private section and, therefore, does not require a 
placard.
    b. For each section of the OFAR compartment created by the 
installation of a curtain, the following requirements of these special 
conditions must be met with the curtain open or closed:
    (1) No-smoking placard (Special Condition 1),
    (2) Emergency illumination (Special Condition 5),
    (3) Aural emergency alarm system (Special Condition 7),
    (4) Seatbelt-fasten signal or return-to-seat signal as applicable 
(Special Condition 8),
    (5) Smoke or fire detection system requirement (Special Condition 
10), and
    (6) Oxygen system (Special Condition 13).
    c. OFAR compartments that are divided by curtains to the extent 
that evacuation could be adversely affected must have exit signs 
directing occupants to the primary stairway outlet. The exit signs must 
be provided in each separated section of the OFAR compartment, except 
for curtained bunks, and must meet the requirements of Sec.  
25.812(b)(1)(i). An exit sign with reduced background area or a 
symbolic exit sign, as described in Special Condition 4(a), may be used 
to meet this requirement.
    d. For OFAR compartments that are divided using an installation of 
a rigid partition with a door separating the sections, the following 
requirements of these special conditions must be met with the door open 
or closed:
    (1) A secondary evacuation route from each section to the main deck 
is required, or alternatively, the applicant must show that any door 
between the sections precludes anyone from being trapped inside a 
section of the compartment. The applicant must consider removal of an 
incapacitated occupant from within this area. A secondary evacuation 
route from a small room designed for only one occupant for a short time 
duration, such as a changing area or lavatory, is not required, but the 
applicant must consider removal of an incapacitated occupant from 
within such a small room.
    (2) Any door between the sections must be shown to be openable when 
crowded against, even when crowding occurs at each side of the door.
    (3) No more than one door may be located between any seat or berth 
and the primary stairway door.
    (4) In each section, exit signs meeting requirements of Sec.  
25.812(b)(1)(i), or shown to have an equivalent level of safety, must 
direct occupants to the primary stairway outlet. An exit sign with 
reduced background area or a symbolic exit sign, as described in 
Special Condition 4(a), may be used to meet this requirement.
    (5) Special Conditions 1 (no-smoking placards), 5 (emergency 
illumination), 7 (emergency alarm system), 8 (fasten-seatbelt signal or 
return to seat signal as applicable), 10 (smoke or fire detections 
system), and 13 (oxygen system) must be met with the door open or 
closed.
    (6) Special Condition 6 (two-way voice communication) and 9 
(Emergency firefighting and protective equipment) must be met 
independently for each separate section except for lavatories or other 
small areas that are not intended to be occupied for extended periods 
of time.
    15. Waste Disposal Receptacle. If a waste-disposal receptacle is 
fitted in the OFAR compartment, it must be equipped with an automatic 
fire extinguisher that meets the performance requirements of Sec.  
25.854(b).
    16. OFAR Compartment Materials. Materials (including finishes or 
decorative surfaces applied to the materials) of OFAR compartments must 
comply with flammability requirements of Sec.  25.853(a) as amended by 
Amendment 25-116. Seat cushions and mattresses must comply with the 
flammability requirements of Sec.  25.853(c) as amended by Amendment 
25-116 and the test requirements of part 25, appendix F, part II, or 
other equivalent methods.
    17. OFAR Compartment Lavatory. A lavatory within the OFAR 
compartment must meet the same requirements as a lavatory installed on 
the main deck except with regard to Special Condition 10 for smoke 
detection.
    18. OFAR Compartment Stowage. Each stowage compartment in the OFAR 
compartment, except for under-seat compartments for occupant 
convenience, must be completely enclosed. All enclosed stowage 
compartments within the OFAR compartment that are not limited to 
stowage of emergency equipment or airplane-supplied equipment (e.g., 
bedding) must meet the design criteria described in table 1 of these 
special conditions. The in-flight accessibility of very large, 
enclosed, stowage compartments and the subsequent impact on the 
crewmembers' ability to effectively reach any part of the compartment 
with the contents of a hand-held fire-extinguishing system will require 
additional fire-protection

[[Page 11841]]

considerations similar to those required for inaccessible compartments 
such as Class C cargo compartments.

   Table 1--Design Criteria for Enclosed Stowage Compartments not Limited to Stowage of Emergency or Airplane-
                                               Supplied Equipment
----------------------------------------------------------------------------------------------------------------
                                            Applicability of fire protection requirements by interior volume
                                      --------------------------------------------------------------------------
       Fire protection features                                  25 cubic feet to less     57 Cubic feet to 200
                                       Less than 25 cubic feet     than 57 cubic feet           cubic feet
----------------------------------------------------------------------------------------------------------------
Compliant Materials of Construction    Yes....................  Yes....................  Yes.
 \a\.
Smoke or Fire Detectors \b\..........  No.....................  Yes....................  Yes.
Liner \c\............................  No.....................  Conditional............  Yes.
Fire Location Detector \d\...........  No.....................  Yes....................  Yes.
----------------------------------------------------------------------------------------------------------------

    a. Materials of Construction: The material used in constructing 
each enclosed stowage compartment must at least be fire resistant and 
must meet the flammability standards established for interior 
components (i.e., 14 CFR part 25 Appendix F, Parts I, IV, and V) per 
the requirements of Sec.  25.853. For compartments less than 25 ft\3\ 
in interior volume, the design must ensure the ability to contain a 
fire likely to occur within the compartment under normal use.
    b. Smoke or Fire Detectors: Enclosed stowage compartments equal to 
or exceeding 25 ft\3\ in interior volume must be provided with a smoke 
or fire detection system to ensure that a fire can be detected within a 
one-minute detection time. The applicant must conduct flight tests to 
show compliance with this requirement. Each smoke or fire detection 
system(s) must provide:
    (1) A visual indication to the flight deck within one minute after 
the start of a fire.
    (2) An aural warning in the OFAR compartment.
    (3) A warning in the main passenger cabin. This warning must be 
readily detectable by a flight attendant, taking into consideration the 
locations of flight attendants throughout the main passenger 
compartment during various phases of flight.
    c. Stowage compartment liner.
    (1) If the material used in constructing the stowage compartment 
meets the flammability requirements of a liner for a Class B cargo 
compartment (Sec.  25.855 at Amendment 25-116, and Appendix F, part I, 
paragraph (a)(2)(ii)), then no liner is required for enclosed stowage 
compartments equal to or greater than 25 ft\3\, but less than 57 ft\3\ 
in interior volume.
    (2) For all enclosed stowage compartments equal to or greater than 
57 ft\3\ in interior volume, but less than or equal to 200 ft\3\, a 
liner must be provided that meets the requirements of Sec.  25.855 for 
a Class B cargo compartment.
    d. Fire Location Detector: If an OFAR compartment has enclosed 
stowage compartments exceeding 25 ft\3\ interior volume that are 
located separately from the other stowage compartments' central 
location, such as the entry to the OFAR compartment or other common 
area, that OFAR compartment requires additional fire protection 
features and devices to assist a firefighter in determining the 
location of that fire.

    Issued in Des Moines, Washington, on February 14, 2020.
James E. Wilborn,
Acting Manager, Transport Standards Branch, Policy and Innovation 
Division, Aircraft Certification Service.
[FR Doc. 2020-03475 Filed 2-27-20; 8:45 am]
 BILLING CODE 4910-13-P


