ALLEGHENY COUNTY HEALTH DEPARTMENT

AIR QUALITY PROGRAM

Subject:	Review Memo for BART Application			May 8, 2008

		Eastman Chemical Resins, Inc.

		P.O. Box 567

		West Elizabeth, PA 15088-0567

		

Operating Permit #: 95-0058

To:		James Thompson             	    		

		Acting Air Quality Program Manager   		

          		Allegheny County Health Department	

From:		Tom Lattner, Air Pollution Control Engineer

		

Through:	Jayme Graham

		Supervisor Planning Section

		Air Quality Program

          		Allegheny County Health Department 

		Sandra Etzel

		Chief Engineer

		Air Quality Program

          		Allegheny County Health Department

	

1.		Background:   Eastman Chemical Resins is a chemical process plant.  
It had 75 units that were initially determined to be BART eligible.  The
company decided to retire four of those units (four tanks) in order to
reduce potential emissions to below 250 tpy for all eligible pollutants.


2.		Process Description:  The Source ID numbers of the BART eligible
units at this facility are listed on the attached table.

3.		Regulatory Analysis:

Eastman Chemical Resins has sources at this facility which were
originally constructed between 1962 and 1977.  To address the BART
requirements, the company elected to retire four tanks.  Tanks 17, 18,
61 and 63 (corresponding to Sources S202, S202, S224 and S226) have been
retired from service and the company has removed them from its Operating
Permit Application.  To memorialize the company’s decision to retire
these tanks, the Allegheny County Health Department issued an Order on
April 24, 2008, stating that “Eastman shall immediately and
permanently render volatile organic storage tanks 17, 18, 61 & 63
unusable for the storage of VOCs.”  (Even before this Order, the ACHD
had conducted an inspection of the tanks in November, 2007, and found
that one had large holes cut into it and the that the piping and
instrumentation had been removed from the others, making it impossible
for the tanks to be placed back into service without making major
modifications.)  As a result, total emissions do not exceed 250 tpy for
any of the eligible pollutants.  Thus the plant’s units are not
subject to the Best Available Retrofit Technology (BART) requirements
that are a part of the Regional Haze rules specified in 40 CFR Part 51,
Subpart P Protection of Visibility.  Finally, were those units subject
to the BART requirements, there currently is not adequate technology
available to determine visibility impairment by individual sources of
VOCs.

BART Analysis:  Not required.

cc:	Nancy Herb, PA DEP, Harrisburg

Eastman Chemicals (Tax I.D. 62-1837994)



Jefferson Site (Facility I.D. 00265)



	BART Category 21 - Chemical Process Plant



	Emissions data taken from Form K of the June 29, 2001 Operating Permit
Application

Type of controls:





	Units within the 1962 - 1977 timeframe







Point	Process Unit	Emission Source	Installation Date	VOCs Potential

 To Emit 

(lb/yr)	VOCs Actual (lb/yr)	PM10 Potential 

To Emit (lb/yr)	PM10 Actual (lb/yr)	NOx Potential To Emit (lb/yr)	NOx
Actual (lb/yr)	SO2 Potential To Emit (lb/yr)	SO2 Actual (lb/yr)

F029	WWPT	PRIMARY CLARIFIER	1976	400	400	*	*	*	*	*	*

F033	WWPT	702-A TANK	1977	3040	2533	*	*	*	*	*	*

F034	WWPT	702-B TANK	1977	3040	2533	*	*	*	*	*	*

F035	WWPT	702-C TANK	1977	3040	2533	*	*	*	*	*	*

F036	WWPT	SLUDGE BATCH TANKS	1976	200	170	*	*	*	*	*	*

F037	WWPT	SLUDGE BATCH TANKS	1976	200	170	*	*	*	*	*	*

S013	WW POLY	FEED DRYERS	1972	28400	24900	*	*	*	*	*	*

S014	WW POLY	WEST BLEND TANK	1972	5280	4620	*	*	*	*	*	*

S015	WW POLY	NORTH BLEND TANK	1978 (In exist Aug 7, 1977)	5280	4620	*	*
*	*	*	*

S017	WW POLY	REACTORS	1972, 1978 (1972 unit applies)	6990	12260	*	*	*	*
*	*

S018	WW POLY	NEUTRALIZER	1972	13980	8840	280	240	*	*	*	*

S020	WW POLY	FILTRATE RECEIVER	1972	5860	5140	*	*	*	*	*	*

S021	WW POLY	AUXILLARY REC	1972	4080	3580	*	*	*	*	*	*

S024	WW POLY	T-74,68,69 TANKS	1974, 1977, 1977	1720	1720	*	*	*	*	*	*

S025	WW POLY	T-73,75,76,77 TANKS	1972, 1972, 1973, 1973	7780	7780	*	*	*
*	*	*

S026	WW POLY	T-67 TANKS	1977	760	760	*	*	*	*	*	*

S038	TANKS	262 TANK (C-5)	1977	80	 	*	*	*	*	*	*

S050	WW POLY	NEUTRALIZER EXHAUST	1972	13980	2960	*	*	*	*	*	*

S077	V8-UNIT	1ST STG VACUUM JET	1964	14740	11247	*	*	*	*	*	*

S078	V8-UNIT	2ND STG VACUUM JET	1964	14740	11247	*	*	*	*	*	*

Point	Process Unit	Emission Source	Installation Date	VOCs Potential

 To Emit 

(lb/yr)	VOCs Actual (lb/yr)	PM10 Potential 

To Emit (lb/yr)	PM10 Actual (lb/yr)	NOx Potential To Emit (lb/yr)	NOx
Actual (lb/yr)	SO2 Potential To Emit (lb/yr)	SO2 Actual (lb/yr)

S079	V-8 UNIT	RK #2	1974	180	47	*	*	*	*	*	*

S080	V-8 UNIT	RK#3	1974	180	47	*	*	*	*	*	*

S081	V-8 UNIT	RK#4	1974	180	47	*	*	*	*	*	*

S087	V-8 UNIT	CB-FURNACE	1973	152	31	200	41	3990	822	24	5

S088	V-8 UNIT	H-8 FURNACE	1974	109	52	144	68	2880	1357	17	8

S093	V-8 UNIT	MIXPOT	1974	376	48	*	*	*	*	*	*

S094	V-8 UNIT	AGITATOR	1974	2258	289	*	*	*	*	*	*

S106	LTC 1 & 2	#CB-FURNACE	1975	152	74	200	98	3990	1956	24	12

S108	LTC 1 & 2	RECLAIM SOLUTION TANK	1975	8150	0	*	*	*	*	*	*

S109	LTC 1 & 2	#1 LTC VACUUM JET	1975	38507	36924	*	*	*	*	*	*

S111	LTC 1 & 2	RK #5	1975	5679	2275	*	*	*	*	*	*

S112	LTC 1 & 2	RK #6	1975	1636	693	*	*	*	*	*	*

S113	LTC 1 & 2	RK#7	1975	1636	693	*	*	*	*	*	*

S114 	LTC 1 & 2	#1 & #2 LTC SANDVIK FLAKERS	1976, 1981 (1976 unit
applies)	3568	1594	*	*	*	*	*	*

S143	BOILER HOUSE	#3-#4 FW BOILER	1950/67	2989	494	7192	1720	72142	16687
309	52

S145	TANKS	21 TANK	1967	11428	 	*	*	*	*	*	*

S147	WWTP	701-A AND 701-B TANK	1976	780	780	*	*	*	*	*	*

S149	WWPT	LIME FLASH MIX TANK	1976	3480	2880	*	*	*	*	*	*

S173	TANKS	8-1-C TANK	1962	5576	405	*	*	*	*	*	*

S174	TANKS	8-1-D TANK	1964	5576	405	*	*	*	*	*	*

S175	TANKS	8-1-E TANK	1966	5576	405	*	*	*	*	*	*

S187	TANKS	R-1-A TANK	1978	9449	851	*	*	*	*	*	*

S188	TANKS	R-1-B TANK	1978	8761	783	*	*	*	*	*	*

S202	TANKS	17 TANK	1966	xxx	xxx	Retired	for 	BART	purposes	xxx	xxx

S203	TANKS	18 TANK	1966	xxx	xxx	Retired	for 	BART	purposes	xxx	xxx

S206	TANKS	22TANK	1971	8875	2483	*	*	*	*	*	*

S207	TANKS	23 TANK	1971	8848	1300	*	*	*	*	*	*

S208	TANKS	24 TANK	1971	11450	155	*	*	*	*	*	*

S209	TANKS	25 TANK	1971	13175	395	*	*	*	*	*	*

S210	TANKS	26 TANK	1970	3288	3288	*	*	*	*	*	*

Point	Process Unit	Emission Source	Installation Date	VOCs Potential

 To Emit 

(lb/yr)	VOCs Actual (lb/yr)	PM10 Potential 

To Emit (lb/yr)	PM10 Actual (lb/yr)	NOx Potential To Emit (lb/yr)	NOx
Actual (lb/yr)	SO2 Potential To Emit (lb/yr)	SO2 Actual (lb/yr)

S211	TANKS	27 TANK	1970	3288	3288	*	*	*	*	*	*

S212	TANKS	28 TANK	1970	3288	3288	*	*	*	*	*	*

S213	TANKS	29 TANK	1970	3288	3288	*	*	*	*	*	*

S224	TANKS	61 TANK	1965	xxx	xxx	Retired	for 	BART	purposes	xxx	xxx

S226	TANKS	63 TANK	1971	xxx	xxx	Retired	for 	BART	purposes	xxx	xxx

S227	TANKS	65 TANK	1977	6596	482	*	*	*	*	*	*

S230	TANKS	71TANK	1972	33302	431	*	*	*	*	*	*

S231	TANKS	72 TANK	1973	22825	166	*	*	*	*	*	*

S232	TANKS	78 TANK	1973	35933	2835	*	*	*	*	*	*

S233	TANKS	83 TANK	1962	9546	0	*	*	*	*	*	*

S234	TANKS	126 TANK	1970	7528	592	*	*	*	*	*	*

S237	HYDROGENATION	T-160, T-161 TANKS	1963	3899	2078	*	*	*	*	*	*

S238	THERMAL POLY	T-162 TANK	1963	6116	2716	*	*	*	*	*	*

S242	TANKS	203 TANK	1971	10082	419	*	*	*	*	*	*

S252	TANKS	257 TANK	1969	2723	82	*	*	*	*	*	*

S255	TANKS	260 TANK (C-5)	1977	80	80	*	*	*	*	*	*

S257	TANKS	263 TANK (C-5)	1977	120	120	*	*	*	*	*	*

S258	TANKS	264 TANK	1977	3732	3732	*	*	*	*	*	*

S259	TANKS	265 TANK	1977	3732	3732	*	*	*	*	*	*

S261	TANKS	360 TANK	1966	2423	29	*	*	*	*	*	*

S262	TANKS	361 TANK	1966	2457	2	*	*	*	*	*	*

S263	TANKS	362 TANK	1966	8238	0	*	*	*	*	*	*

S264	TANKS	363 TANK	1966	11218	11218	*	*	*	*	*	*

S265	TANKS	364 TANK	1966	11218	11218	*	*	*	*	*	*

S299	WWPT	SUMPS/DAF	1976	580	580	*	*	*	*	*	*



	TOTAL lbs/yr	487816	215827	8016	2167	83002	20822	374	77



	TOTAL tons/yr	243.91	107.91	4.01	1.08	41.50	10.41	0.19	0.04





(PTE)	(Actual)	(PTE)	(Actual)	(PTE)	(Actual)	(PTE)	(Actual)













	* = Not on Form K



DATA FOR RETIRED UNITS

Point	Process Unit	Emission Source	Installation Date	VOCs Potential

 To Emit 

(lb/yr)	VOCs Actual (lb/yr)	PM10 Potential 

To Emit (lb/yr)	PM10 Actual (lb/yr)	NOx Potential To Emit (lb/yr)	NOx
Actual (lb/yr)	SO2 Potential To Emit (lb/yr)	SO2 Actual (lb/yr)

S202	TANKS	17 TANK	1966	11174	721	*	*	*	*	*	*

S203	TANKS	18 TANK	1966	8337	681	*	*	*	*	*	*

S224	TANKS	61 TANK	1965	14132	2502	*	*	*	*	*	*

S226	TANKS	63 TANK	1971	2207	125	*	*	*	*	*	*



