                             SUPPORTING STATEMENT
	ENVIRONMENTAL PROTECTION AGENCY
	
NSPS for Lime Manufacturing (40 CFR Part 60, Subpart HH) (Renewal) 

1.  Identification of the Information Collection

      1(a)  Title of the Information Collection

NSPS for Lime Manufacturing (40 CFR Part 60, Subpart HH) (Renewal), EPA ICR Number 1167.11, OMB Control Number 2060-0063. 

      1(b)  Short Characterization/Abstract		

      The New Source Performance Standards (NSPS) for Lime Manufacturing were proposed on May 3, 1977, promulgated on April 26, 1984, and amended on October 17, 2000.  These regulations apply to each rotary lime kiln used in the manufacturing of lime that commenced  construction or reconstruction after the date of proposal.  The standard does not apply to facilities used in the manufacture of lime at kraft pulp mills. This information is being collected to assure compliance with 40 CFR Part 60, Subpart HH.

      In general, all NSPS standards require initial notifications, performance tests, and periodic reports by the owners/operators of the affected facilities.  They are also required to maintain records of the occurrence and duration of any startup, shutdown, or malfunction in the operation of an affected facility, or any period during which the monitoring system is inoperative.  These notifications, reports, and records are essential in determining compliance, and are required of all affected facilities subject to NSPS.  

--------------------------------------------------------------------------------
      Any owner/operator subject to the provisions of this part shall maintain a file of these measurements, and retain the file for at least two years following the date of such measurements, maintenance reports, and records.  All reports are sent to the delegated state or local authority.  In the event that there is no such delegated authority, the reports are sent directly to the United States Environmental Protection Agency (EPA) regional office. 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
        Based on our consultations with industry representatives, there are an average of 2.47  affected facilities at each plant site and that each plant site has only one respondent (i.e., the owner/operator of the plant site).
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Over the next three years, an average of 41 respondents per year will be subject to the standard, and no additional respondents per year will become subject to the standard.  
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The Office of Management and Budget (OMB) approved the currently active ICR without any "Terms of Clearance." 
--------------------------------------------------------------------------------
      
	All of the lime manufacturers in the United States are owned and operated by the lime manufacturing industry (the "Affected Public"), which is privately, owned for-profit business.  None of these facilities in the United States are owned by state, local, tribal or the Federal government.  The burden to the "Affected Public" may be found in Table 1: Annual Respondent Burden and Cost  -  NSPS for Lime Manufacturing (40 CFR Part 60, Subpart HH) (Renewal).  The "Federal Government" burden is attributed entirely to work performed by federal employees or government contractors and may be found in  Table 2: Average Annual EPA Burden and Cost  -  NSPS for Lime Manufacturing (40 CFR Part 60, Subpart HH) (Renewal). 

--------------------------------------------------------------------------------
2.  Need for and Use of the Collection
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      2(a)  Need/Authority for the Collection
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The EPA is charged under Section 111 of the Clean Air Act (CAA), as amended, to establish standards of performance for new stationary sources that reflect: 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            . . . application of the best technological system of continuous emissions reduction which (taking into consideration the cost of achieving such emissions reduction, or any non-air quality health and environmental impact and energy requirements) the Administrator determines has been adequately demonstrated.  Section 111(a)(l).
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
The Agency refers to this charge as selecting the best demonstrated technology (BDT).  Section 111 also requires that the Administrator review and, if appropriate, revise such standards every four years.   In addition, section 114(a) states that the Administrator may require any owner/operator subject to any requirement of this Act to: 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            (A) Establish and maintain such records; (B) make such reports; (C) install, use, and maintain such monitoring equipment, and use such audit procedures, or methods; (D) sample such emissions (in accordance with such procedures or methods, at such locations, at such intervals, during such periods, and in such manner as the Administrator shall prescribe); (E) keep records on control equipment parameters, production variables or other indirect data when direct monitoring of emissions is impractical; (F) submit compliance certifications in accordance with Section 114(a)(3); and (G) provide such other information as the Administrator may reasonably require.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      In the Administrator's judgment, particulate matter (PM) emissions from lime manufacturing plants cause or contribute to air pollution that may reasonably be anticipated to endanger public health or welfare.  Therefore, the NSPS were promulgated for this source category at 40 CFR Part 60, Subpart HH.
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      2(b)  Practical Utility/Users of the Data
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The recordkeeping and reporting requirements in the standard ensure compliance with the applicable regulations which were promulgated in accordance with the Clean Air Act.  The collected information is also used for targeting inspections and as evidence in legal proceedings.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Performance tests are required in order to determine an affected facility's initial capability to comply with the emission standard. Continuous emission monitors are used to ensure compliance with the standard at all times. During the performance test a record of the operating parameters under which compliance was achieved may be recorded and used to determine compliance in place of a continuous emission monitor.  
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The notifications required in the standard are used to inform the Agency or delegated authority when a source becomes subject to the requirements of the regulations.  The reviewing authority may then inspect the source to check if the pollution control devices are properly installed and operated, leaks are being detected and repaired, and the standard is being met.  The performance test may also be observed.
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      The required semiannual reports are used to determine periods of excess emissions, identify problems at the facility, verify operation/maintenance procedures and for compliance determinations.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
3.  Nonduplication, Consultations, and Other Collection Criteria
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The requested recordkeeping and reporting are required under 40 CFR Part 60, Subpart HH.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      3(a)  Nonduplication
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
       If the subject standards have not been delegated, the information is sent directly to the appropriate EPA regional office.  Otherwise, the information is sent directly to the delegated state or local agency.  If a state or local agency has adopted its own similar standards to implement the Federal standards, a copy of the report submitted to the state or local agency can be sent to the Administrator in lieu of the report required by the Federal standards.  Therefore, no duplication exists.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      3(b)  Public Notice Required Prior to ICR Submission to OMB
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      An announcement of a public comment period for the renewal of this ICR was published in the Federal Register (79 FR 30117) on May 27, 2014.  No comments were received on the burden published in the Federal Register. 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      3(c)  Consultations

      The Agency has consulted industry experts and internal data sources to project the number of affected facilities and industry growth over the next three years.  The primary source of information as reported by industry, in compliance with the recordkeeping and reporting provisions in the standard, is Enforcement and Compliance History Online (ECHO), which is operated and maintained by EPA's Office of Compliance.  ECHO is EPA's database for the collection, maintenance, and retrieval of all compliance data.  The growth rate for the industry is based on our consultations with the Agency's internal industry experts.

      Industry trade associations and other interested parties were provided an opportunity to comment on the burden associated with the standard as it was being developed.  In developing this ICR, we contacted both the National Lime Association, at (707) 243-5463, and the Carmeuse Lime & Stone, at (412) 995-5500.
      
--------------------------------------------------------------------------------
      It is our policy to respond after a thorough review of comments received since the last ICR renewal as well as those submitted in response to the first Federal Register notice.
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      3(d)  Effects of Less Frequent Collection
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Less frequent information collection would decrease the margin of assurance that facilities are continuing to meet the standards.  Requirements for information gathering and recordkeeping are useful techniques to ensure that good operation and maintenance practices are applied and emission limitations are met.  If the information required by these standards was collected less frequently, the proper operation and maintenance of control equipment and the possibility of detecting violations would be less likely.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      3(e)  General Guidelines
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      These reporting or recordkeeping requirements do not violate any of the regulations promulgated by OMB under 5 CFR Part 1320, Section 1320.5.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      3(f)  Confidentiality
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Any information submitted to the Agency for which a claim of confidentiality is made will be safeguarded according to the Agency policies set forth in Title 40, chapter 1, part 2, subpart B - Confidentiality of Business Information (see 40 CFR 2; 41 FR 36902, September 1, 1976; amended by 43 FR 40000, September 8, 1978; 43 FR 42251, September 20, 1978; 44 FR 17674, March 23, 1979).
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      3(g)  Sensitive Questions
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The reporting or recordkeeping requirements in the standard do not include sensitive questions.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
4.  The Respondents and the Information Requested
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      4(a)  Respondents/SIC Codes
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The respondents to the recordkeeping and reporting requirements are lime manufacturing plants.  The United States Standard Industrial Classification (SIC) code for the respondents affected by the standards is SIC 3274, which corresponds to the North American Industry Classification System (NAICS) 327410 for Lime Manufacturing.  
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      4(b)  Information Requested 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            (i)  Data Items
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      In this ICR, all the data that is recorded or reported is required by the NSPS for Lime Manufacturing (40 CFR Part 60, Subpart HH).  
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      A source must make the following reports:
--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Notifications
--------------------------------------------------------------------------------
Notification of construction/reconstruction
--------------------------------------------------------------------------------
60.7(a)(1)
--------------------------------------------------------------------------------
Notification of actual startup
--------------------------------------------------------------------------------
60.7(a)(3)
--------------------------------------------------------------------------------
Notification of any physical or operational change
--------------------------------------------------------------------------------
60.7(a)(4)
--------------------------------------------------------------------------------
Notification of demonstration of continuous monitoring system (CMS)
--------------------------------------------------------------------------------
60.7(a)(4)
--------------------------------------------------------------------------------
Notification of the anticipated date of the performance test
--------------------------------------------------------------------------------
60.7(a)(6)
--------------------------------------------------------------------------------
Notification that continuous monitoring system data will be used to determine compliance
--------------------------------------------------------------------------------
60.7(a)(7)
--------------------------------------------------------------------------------
Initial performance test results
--------------------------------------------------------------------------------
60.8(a)
--------------------------------------------------------------------------------
Semiannual excess emissions report
--------------------------------------------------------------------------------
60.7(c)
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      A source must keep the following records:
--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Recordkeeping
--------------------------------------------------------------------------------
Record of startup, shutdown, and malfunctions
--------------------------------------------------------------------------------
60.7(b)
--------------------------------------------------------------------------------
Records are required to be retained for two years
--------------------------------------------------------------------------------
60.7(f)
--------------------------------------------------------------------------------
Observe and record Method 9 opacities
--------------------------------------------------------------------------------
60.344(b)(4), 60.11(b)
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
Electronic Reporting
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Some of the respondents are using monitoring equipment that automatically records parameter data.  Although personnel at the affected facility must still evaluate the data, internal automation has significantly reduced the burden associated with monitoring and recordkeeping at a plant site. 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Also, regulatory agencies in cooperation with the respondents continue to create reporting systems to transmit data electronically.  However, electronic reporting systems are still not widely used.  At this time, it is estimated that approximately 10  percent of the respondents use electronic reporting.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            (ii)  Respondent Activities	
--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Respondent Activities

--------------------------------------------------------------------------------
Read instructions.

--------------------------------------------------------------------------------
Install, calibrate, maintain, and operate CMS for opacity, or for pressure drop and liquid supply pressure for wet scrubber.

--------------------------------------------------------------------------------
Perform initial performance test, Reference Method 9 test, and repeat performance tests if necessary.

--------------------------------------------------------------------------------
Write the notifications and reports listed above.

--------------------------------------------------------------------------------
Enter information required to be recorded above.

--------------------------------------------------------------------------------
Submit the required reports developing, acquiring, installing, and utilizing technology and systems for the purpose of collecting, validating, and verifying information.

--------------------------------------------------------------------------------
Develop, acquire, install, and utilize technology and systems for the purpose of processing and maintaining information.

--------------------------------------------------------------------------------
Develop, acquire, install, and utilize technology and systems for the purpose of disclosing and providing information.

--------------------------------------------------------------------------------
Train personnel to be able to respond to a collection of information.

--------------------------------------------------------------------------------
Transmit, or otherwise disclose the information.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Currently sources are using monitoring and reporting equipment that provide parameter data in an automated way e.g., continuous parameter monitoring system.  Although personnel at the source still need to evaluate the data, this type of monitoring equipment has significantly reduced the burden associated with monitoring and recordkeeping. 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
5.  The Information Collected:  Agency Activities, Collection Methodology, and Information Management
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      5(a)  Agency Activities  
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      EPA conducts the following activities in connection with the acquisition, analysis, storage, and distribution of the required information.
--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Agency Activities

--------------------------------------------------------------------------------
Review notifications and reports, including performance test reports, and excess emissions reports, required to be submitted by industry.

--------------------------------------------------------------------------------
Audit facility records.

--------------------------------------------------------------------------------
Input, analyze, and maintain data in Integrated Compliance Information System (ICIS) and ECHO.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      5(b)  Collection Methodology and Management
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Following notification of startup, the reviewing authority could inspect the source to determine whether the pollution control devices are properly installed and operated. Performance test reports are used by the Agency to discern a source's initial capability to comply with the emission standard, and note the operating conditions under which compliance was achieved.  Data and records maintained by the respondents are tabulated and published for use in compliance and enforcement programs.  The semiannual reports are used for problem identification, as a check on source operation and maintenance, and for compliance determinations.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Information contained in the reports is reported by state and local governments in the ICIS Air database which is operated and maintained by EPA's Office of Compliance.  ICIS is EPA's database for the collection, maintenance, and retrieval of compliance data for industrial and government-owned facilities.  EPA uses ICIS for tracking air pollution compliance and enforcement by local and state regulatory agencies, EPA regional offices and EPA headquarters.  EPA and its delegated Authorities can edit, store, retrieve and analyze the data.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
       The records required by this regulation must be retained by the owner/operator for two years.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      5(c)  Small Entity Flexibility
--------------------------------------------------------------------------------
	
--------------------------------------------------------------------------------
      A majority of the respondents are large entities (i.e., large businesses).  However, the impact on small entities (i.e., small businesses) was taken into consideration during the development of the regulation.  Due to technical considerations involving the process operations and the types of control equipment employed, the recordkeeping and reporting requirements are the same for both small and large entities.  The Agency considers these to be the minimum requirements needed to ensure compliance and, therefore, cannot reduce them further for small entities.  To the extent that larger businesses can use economies of scale to reduce their burden, the overall burden will be reduced.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      5(d)  Collection Schedule
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The specific frequency for each information collection activity within this request is shown in below Table 1: Annual Respondent Burden and Cost  -  NSPS for Lime Manufacturing (40 CFR Part 60, Subpart HH) (Renewal).
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
6.  Estimating the Burden and Cost of the Collection
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Table 1 documents the computation of individual burdens for the recordkeeping and reporting requirements applicable to the industry for the subpart included in this ICR.  The individual burdens are expressed under standardized headings believed to be consistent with the concept of burden under the Paperwork Reduction Act.  Where appropriate, specific tasks and major assumptions have been identified.  Responses to this information collection are mandatory.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The Agency may not conduct or sponsor, and a person is not required to respond to, a collection of information unless it displays a currently valid OMB Control Number.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      6(a)  Estimating Respondent Burden
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The average annual burden to industry over the next three years from these recordkeeping and reporting requirements is estimated to be 3,772 (Total Labor Hours from Table 1).   These hours are based on Agency studies and background documents from the development of the regulation, Agency knowledge and experience with the NSPS program, the previously approved ICR, and any comments received.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      6(b)  Estimating Respondent Costs
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            (i)  Estimating Labor Costs 
--------------------------------------------------------------------------------
 
--------------------------------------------------------------------------------
      This ICR uses the following labor rates: 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            Managerial	$129.93 ($61.87 + 110%)   
--------------------------------------------------------------------------------
            Technical	$103.97 ($49.51 + 110%)
--------------------------------------------------------------------------------
            Clerical	$51.79 ($24.66 + 110%)
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
These rates are from the United States Department of Labor, Bureau of Labor Statistics, June 2014, "Table 2. Civilian Workers, by occupational and industry group."  The rates are from column 1, "Total compensation."  The rates have been increased by 110 percent to account for the benefit packages available to those employed by private industry.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            (ii)  Estimating Capital/Startup and Operation and Maintenance Costs
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      The type of industry costs associated with the information collection activities in the subject standard are both labor costs which are addressed elsewhere in this ICR and the costs associated with continuous monitoring.  The capital/startup costs are one time costs when a facility becomes subject to the regulation.  The annual operation and maintenance costs are the ongoing costs to maintain the monitor and other costs such as photocopying and postage.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            (iii)  Capital/Startup vs. Operation and Maintenance (O&M) Costs
--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Capital/Startup vs. Operation and Maintenance (O&M) Costs

--------------------------------------------------------------------------------
(A)
--------------------------------------------------------------------------------
Continuous Monitoring Device

--------------------------------------------------------------------------------
(B)
--------------------------------------------------------------------------------
Capital/Startup Cost for One Respondent

--------------------------------------------------------------------------------
(C)
--------------------------------------------------------------------------------
Number of New Respondents 

--------------------------------------------------------------------------------
(D)
--------------------------------------------------------------------------------
Total Capital/Startup Cost,  (B X C)

--------------------------------------------------------------------------------
(E)
--------------------------------------------------------------------------------
Annual O&M Costs for One Respondent

--------------------------------------------------------------------------------
(F)
--------------------------------------------------------------------------------
Number of Respondents  with O&M

--------------------------------------------------------------------------------
(G)
--------------------------------------------------------------------------------
Total O&M,
--------------------------------------------------------------------------------
(E X F)
--------------------------------------------------------------------------------
Continuous Opacity Monitor
--------------------------------------------------------------------------------
$15,000
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
$0
--------------------------------------------------------------------------------
$1,500
--------------------------------------------------------------------------------
41
--------------------------------------------------------------------------------
$61,500
--------------------------------------------------------------------------------
 	
--------------------------------------------------------------------------------
      The total capital/startup costs for this ICR are $0.  This is the total of column D in the above table. 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The total operation and maintenance (O&M) costs for this ICR are $61,500.  This is the total of column G. 
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      The average annual cost for capital/startup and operation and maintenance costs to industry over the next three years of the ICR is estimated to be $61,500.   
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      6(c)  Estimating Agency Burden and Cost
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The only costs to the Agency are those costs associated with analysis of the reported information.  EPA's overall compliance and enforcement program includes activities such as the examination of records maintained by the respondents, periodic inspection of sources of emissions, and the publication and distribution of collected information. 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The average annual Agency cost during the three years of the ICR is estimated to be $17,168.  
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      This cost is based on the average hourly labor rate as follows:

		Managerial	$62.90 (GS-13, Step 5, $39.31 + 60%) 
		Technical	$46.67 (GS-12, Step 1, $29.17 + 60%)
		Clerical	$25.25 (GS-6, Step 3, $15.78 + 60%)
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
These rates are from the Office of Personnel Management (OPM), 2014 General Schedule, which excludes locality rates of pay.  The rates have been increased by 60 percent to account for the benefit packages available to government employees.  Details upon which this estimate is based appear below in Table 2: Average Annual EPA Burden and Cost  -  NSPS for Lime Manufacturing (40 CFR Part 60, Subpart HH) (Renewal).
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      6(d)  Estimating the Respondent Universe and Total Burden and Costs
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Based on our research for this ICR, on average over the next three years, approximately 41 existing respondents will be subject to the standard.  It is estimated that no additional respondents per year will become subject.  The overall average number of respondents, as shown in the table below, is 41 per year.  
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The number of respondents is calculated using the following table that addresses the three years covered by this ICR.  
--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Number of Respondents

--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Respondents That Submit Reports

--------------------------------------------------------------------------------
Respondents That Do Not Submit Any Reports

--------------------------------------------------------------------------------


--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
Year

--------------------------------------------------------------------------------
(A)
--------------------------------------------------------------------------------
Number of New Respondents [1]

--------------------------------------------------------------------------------
(B)
--------------------------------------------------------------------------------
Number of Existing Respondents

--------------------------------------------------------------------------------
(C)
--------------------------------------------------------------------------------
Number of Existing  Respondents that keep records but do not submit reports

--------------------------------------------------------------------------------
(D)
--------------------------------------------------------------------------------
Number of Existing Respondents That Are Also New Respondents

--------------------------------------------------------------------------------
(E)
--------------------------------------------------------------------------------
Number of Respondents
--------------------------------------------------------------------------------
(E=A+B+C-D)

--------------------------------------------------------------------------------
1
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
41
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
41

--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
41
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
41

--------------------------------------------------------------------------------
3
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
41
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
41

--------------------------------------------------------------------------------
Average
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
41
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
41
--------------------------------------------------------------------------------
      [1] New respondents include sources with constructed, reconstructed and modified affected facilities.  
--------------------------------------------------------------------------------
                                                
--------------------------------------------------------------------------------
      Column D is subtracted to avoid double-counting respondents.  As shown above, the average Number of Respondents over the three year period of this ICR is 41. 
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      The total number of annual responses per year is calculated using the following table: 
--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Total Annual Responses
                                       
--------------------------------------------------------------------------------
(A)
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
Information Collection Activity
                                       
--------------------------------------------------------------------------------
(B)
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
Number of Respondents
                                       
--------------------------------------------------------------------------------
(C)
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
Number of Responses
                                       
--------------------------------------------------------------------------------
(D)
--------------------------------------------------------------------------------
Number of Existing Respondents That Keep Records But Do Not Submit Reports
                                       
--------------------------------------------------------------------------------
(E)
--------------------------------------------------------------------------------
Total Annual  Responses
--------------------------------------------------------------------------------
E=(BxC)+D
--------------------------------------------------------------------------------
Notification of initial performance test
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
1
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
Notification of any physical or operational changes
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
1
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
Notification of demonstration of CMS
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
1
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
Notification that continuous monitoring system (CMS)
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
1
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
Semiannual excess emission report
--------------------------------------------------------------------------------
41
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
82
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------

--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
Total
--------------------------------------------------------------------------------
82
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The number of Total Annual Responses is 82.  
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The total annual labor costs are $379,317.  Details regarding these estimates may be found below in Table 1: Annual Respondent Burden and Cost  -  NSPS for Lime Manufacturing (40 CFR Part 60, Subpart HH) (Renewal).
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      6(e)  Bottom Line Burden Hours and Cost Tables
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The detailed bottom line burden hours and cost calculations for the respondents and the Agency are shown in Tables 1 and 2, respectively, and summarized below.  
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            (i) Respondent Tally
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The total annual labor hours are 3,772.  Details regarding these estimates may be found in Table 1: Annual Respondent Burden and Cost  -  NSPS for Lime Manufacturing (40 CFR Part 60, Subpart HH) (Renewal).  
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      Furthermore, the annual public reporting and recordkeeping burden for this collection of information is estimated to average 46 hours per response.
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      The total annual capital/startup and O&M costs to the regulated entity are $61,500.  The cost calculations are detailed in Section 6(b)(iii), Capital/Startup vs. Operation and Maintenance (O&M) Costs.
--------------------------------------------------------------------------------
                  
--------------------------------------------------------------------------------
            (ii) The Agency Tally
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The average annual Agency burden and cost over next three years is estimated to be 377 labor hours at a cost of $17,168.  See Table 2: Average Annual EPA Burden and Cost  -  NSPS for Lime Manufacturing (40 CFR Part 60, Subpart HH) (Renewal).
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      6(f)  Reasons for Change in Burden
--------------------------------------------------------------------------------

      There is no change in the labor hours in this ICR compared to the previous ICR.  However, there is an increase in the estimated labor cost as currently identified in the OMB Inventory of Approved Burdens.  The increase is not due to any program changes.  The change in burden is due to the use of the most updated labor rates.  
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      6(g)  Burden Statement
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The annual public reporting and recordkeeping burden for this collection of information is estimated to average 46 hours per response.  Burden means the total time, effort, or financial resources expended by persons to generate, maintain, retain, or disclose or provide information to or for a Federal agency.  This includes the time needed to review instructions; develop, acquire, install, and utilize technology and systems for the purposes of collecting, validating, and verifying information, processing and maintaining information, and disclosing and providing information; adjust the existing ways to comply with any previously applicable instructions and requirements; train personnel to be able to respond to a collection of information; search data sources; complete and review the collection of information; and transmit or otherwise disclose the information.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      An agency may not conduct or sponsor, and a person is not required to respond to, a collection of information unless it displays a valid OMB Control Number.  The OMB Control Numbers for EPA regulations are listed at 40 CFR Part 9 and 48 CFR Chapter 15.

	To comment on the Agency's need for this information, the accuracy of the provided burden estimates, and any suggested methods for minimizing respondent burden, including the use of automated collection techniques, EPA has established a public docket for this ICR under Docket ID Number EPA-HQ-OECA-2014-0042.  An electronic version of the public docket is available at http://www.regulations.gov/ which may be used to obtain a copy of the draft collection of information, submit or view public comments, access the index listing of the contents of the docket, and to access those documents in the public docket that are available electronically.  When in the system, select "search," then key in the docket ID number identified in this document.  The documents are also available for public viewing at the Enforcement and Compliance Docket and Information Center in the EPA Docket Center (EPA/DC), EPA West, Room 3334, 1301 Constitution Ave., NW, Washington, DC.  The EPA Docket Center Public Reading Room is open from 8:30 a.m. to 4:30 p.m., Monday through Friday, excluding legal holidays.  The telephone number for the Reading Room is (202) 566-1744, and the telephone number for the docket center is (202) 566-1927.  Also, you can send comments to the Office of Information and Regulatory Affairs, Office of Management and Budget, 725 17th Street, NW, Washington, DC 20503, Attention: Desk Officer for EPA.  Please include the EPA Docket ID Number EPA-HQ-OECA-2014-0042 and OMB Control Number 2060-0063 in any correspondence. 

Part B of the Supporting Statement

This part is not applicable because no statistical methods were used in collecting this information.

Table 1: Annual Respondent Burden and Cost  -  NSPS for Lime Manufacturing (40 CFR Part 60, Subpart HH) (Renewal) 

                                  Burden item
                                     (A) 
                          Person-hours per occurrence
                                     (B) 
                  No.  Of occurrences per respondent per year
                                     (C) 
                 Person-hours per respondent per year (C=AxB)
                         (D) Respondents per year (a)
                  (E) Technical person-hours per year (E=CxD)
                 (F) Management person-hours per year (Ex0.05)
                  (G) Clerical person-hours per year (Ex0.1)
                                     (H) 
                                  Cost, $ (b)
1.  Applications
                                      N/A
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
2.  Survey and Studies
                                      N/A
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
3.  Reporting Requirements
                                       
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
  A.  Read instructions
                                       1
                                       1
                                       1
                                       0
                                       0
                                       0
                                       0
                                                                             $0
  B.  Required activities:
                                       
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
        Initial performance tests  [c]
                                      280
                                       1
                                      280
                                       0
                                       0
                                       0
                                       0
                                                                             $0
        Reference Method 9 Test [d]
                                       4
                                      1.2
                                      4.8
                                       0
                                       0
                                       0
                                       0
                                                                             $0
        Repeat of performance test [e]
                                      280
                                      0.2
                                      56
                                       0
                                       0
                                       0
                                       0
                                                                             $0
 C.   Create information
                                Included in 3B
                                       
                                       
                                       
                                       
                                       
                                                                              
 D.  Gather Existing Information
                                Included in 3B
                                       
                                       
                                       
                                       
                                       
                                                                              
 E.  Write report
                                       
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
      Notification of construction / reconstruction
                                       2
                                       1
                                       2
                                       0
                                       0
                                       0
                                       0
                                                                             $0
      Notification of actual startup
                                       2
                                       1
                                       2
                                       0
                                       0
                                       0
                                       0
                                                                             $0
      Notification of initial                        
                                       2
                                       1
                                       2
                                       0
                                       0
                                       0
                                       0
                                                                             $0
     performance test
                                       
                                       
                                       
                                       
                                       
                                       
                                       
 
     Notification of any physical or operational change
                                       2
                                       1
                                       2
                                       0
                                       0
                                       0
                                       0
                                                                             $0
     Notification of demonstration of continuous monitoring system
                                       2
                                       1
                                       2
                                       0
                                       0
                                       0
                                       0
                                                                             $0
     Notification that continuous monitoring system (CMS)
                                       2
                                       1
                                       2
                                       0
                                       0
                                       0
                                       0
                                                                             $0
     Semiannual excess emissions f reports
                                       8
                                       2
                                      16
                                      41
                                      656
                                     32.8
                                     65.6
                                                                     $75,863.45
     Performance test results
                                Included in 3B
                                       
                                       
                                       
                                       
                                       
 
SUBTOTAL Reporting
                                      754
                                                                     $75,863.45
4.  Recordkeeping requirements
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
     A.  Read instructions
                                Included in 3A
                                       
                                       
                                       
                                       
                                       
                                                                              
 B.  Plan activities
                                Included in 3B
                                       
                                       
                                       
                                       
                                       
                                                                              
C.  Implement activities
                                Included in 3B
                                       
                                       
                                       
                                       
                                       
                                                                              
D.  Develop record system
                                      N/A
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
E.  Time to enter information
                                       
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
     Records of CMS operating g parameters
                                     0.25
                                      250
                                     62.5
                                      41
                                    2,562.5
                                    128.13
                                    256.25
                                                                    $296,341.59
     Records of startup, shutdown,  malfunction
                                      1.5
                                       1
                                      1.5
                                      41
                                     61.5
                                     3.08
                                     6.15
                                                                      $7,112.20
F.  Time to train personnel
                                      N/A
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
G. Time for audits
                                      N/A
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
SUBTOTAL Recordkeeping
                                     3,018
                                                                    $303,453.79
TOTAL LABOR BURDEN AND COST 
                                       
                                                                               
(rounded)
                                     3,772
                                                                      $379,317 
Capital and O&M Costs
                                                                        $61,500
Grand Total (Labor Cost + Capital/O&M)
                                                                       $440,817

Assumptions:
[a]  We have assumed that the average number of respondents that will be subject to the rule will be 41, and no additional new sources will become subject to the rule over the three-year period of this ICR. 
[b]  This ICR uses the following labor rates: $129.93 per hour for Executive, Administrative, and Managerial labor; $103.97 per hour for Technical labor, and $51.79 per hour for Clerical labor.  These rates are from the United States Department of Labor, Bureau of Labor Statistics, June 2014, "Table 2: Civilian Workers, by Occupational and Industry group."  The rates are from column 1, "Total Compensation."  The rates have been increased by 110% to account for the benefit packages available to those employed by private industry.
[c]  We have assumed that it will take 280 hours to complete a performance test.
[d]  It will take respondents 4 hours to conduct a reference Method 9 test.
[e]  We have assumed that 20 percent of new respondents will have to repeat the performance test.
[f]  We have assumed that it will take 8 hour two times per year for each respondent to complete the semiannual report of exceedances. 
[g]  We have assumed that it will take 250 days per year to record CMS operating parameters information.
[h]  We have assumed that it will take 1.5 hours once a year to record information on startup, shutdown, and  malfunction
Table 2: Average Annual EPA Burden and Cost  -  NSPS for Lime Manufacturing (40 CFR Part 60, Subpart HH) (Renewal)

                                   Activity
                                      (A)
                        EPA person-hours per occurrence
                                      (B)
                     No. of occurrences per plant per year
                                      (C)
                  EPA person-hours per plant per year (C=AxB)
                                      (D)
                            Plants Per Year  [a, c]
                  (E) Technical person-hours per year (E=CxD)
                 (F) Management person-hours per year (Ex0.05)
                  (G) Clerical person-hours per year (Ex0.10)
                                      (H)
                                  Cost, $ [b]
Initial  performance tests [c]
                                      38
                                       1
                                      38
                                       0
                                       0
                                       0
                                       0
                                      $0
Repeat  performance test [d]
                                      38
                                      0.2
                                      7.6
                                       0
                                       0
                                       0
                                       0
                                      $0
Report Review:
                                       
                                       
                                       
                                       
                                       
                                       
                                       
                                       
   Notification of  [e] construction/reconstruction
                                       2
                                       1
                                       2
                                       0
                                       0
                                       0
                                       0
                                      $0
   Notification of actual startup
                                      0.5
                                       1
                                      0.5
                                       0
                                       0
                                       0
                                       0
                                      $0
   Notification of physical or  f operational change
                                      0.5
                                      1.2
                                      0.6
                                       0
                                       0
                                       0
                                       0
                                      $0
    Notification of demonstration of CMS 
                                      0.5
                                       1
                                      0.5
                                       0
                                       0
                                       0
                                       0
                                      $0
    Notification of CMS data to determine compliance
                                      0.5
                                       1
                                      0.5
                                       0
                                       0
                                       0
                                       0
                                      $0
   Performance test results [g]
                                       8
                                      1.2
                                      9.6
                                       0
                                       0
                                       0
                                       0
                                      $0
    Semiannual report [h]
                                       4
                                       2
                                       8
                                      41
                                      328
                                     16.4
                                     32.8
                                  $17,167.52
TOTAL ANNUAL BURDEN AND COST 
                                     377.2
                                  $17,167.52
(rounded)
                                      377
                                    $17,168

Assumptions:
a  We have assumed that there are approximately 41 respondents currently operating in the United States which are subject to the regulation.  It is estimated that no additional respondents will become subject to the regulation in the next three years based on information available on the sector.  Therefore, the average number of respondents per year is estimated to be 41.
b  This cost is based on the following labor rates which incorporates a 1.6 benefits multiplication factor to account for government overhead expenses:  Managerial rate of $62.90 (GS-13, Step 5, $39.31 + 60%), Technical rate of $46.67 (GS-12, Step 1, $29.17 + 60%), and Clerical rate of $25.25 (GS-6, Step 3, $15.78 + 60%).  These rates are from the Office of Personnel Management (OPM) "2014 General Schedule" which excludes locality rates of pay.
    [c]  We have assumed that it will take 38 hours to perform an initial performance test. 
    [d]  We have assumed that 20 percent of new respondents will have to repeat the performance test.
    [e]  It will take 2 hours to review construction/reconstruction report.
 [f]  It will take 0.5 hours to review the physical or operational change review.
[g]  We have assumed that it will take 8 hours to review the performance test results report.
    h  We have assumed that it will take 4 hour two times per year for each respondent to review the semiannual report. 

