                             SUPPORTING STATEMENT
	ENVIRONMENTAL PROTECTION AGENCY
	
NSPS for Portland Cement Plants (40 CFR Part 60, Subpart F) (Renewal) 

1.  Identification of the Information Collection

      1(a)  Title of the Information Collection

NSPS for Portland Cement Plants (40 CFR Part 60, Subpart F) (Renewal),                               EPA ICR Number 1051.13, OMB Control Number 2060-0025. 

      1(b)  Short Characterization/Abstract

      The New Source Performance Standards (NSPS) for Portland Cement Plants were proposed on August 17, 1971, and promulgated on December 23, 1971.  These regulations were revised on: December 14, 1988; October 17, 2000; September 9, 2010; and most-recently on February 12, 2013.  The NSPS applies to the following emission units in Portland cement plants: kilns, clinker coolers, raw mill systems, raw mill dryers, raw material storage, clinker storage, finished product storage, conveyor transfer points, bagging and bulk loading and unloading systems.  The final amendment reduces emission limits for nitrogen oxides (NOx), sulfur dioxide (SO2), and particulate matter (PM) from new kilns constructed or modified June 16, 2008, and requires continuous emissions monitoring for each of the three pollutants.  This information is being collected to assure compliance with 40 CFR Part 60, Subpart F.

      In general, all NSPS standards require initial notifications, performance tests, and periodic reports by the owners/operators of the affected facilities.  They are also required to maintain records of the occurrence and duration of any startup, shutdown, or malfunction in     the operation of an affected facility, or any period during which the monitoring system is inoperative.  These notifications, reports, and records are essential in determining compliance, and are required of all affected facilities subject to NSPS.  

--------------------------------------------------------------------------------
      Any owner/operator subject to the provisions of this part shall maintain a file of these measurements, and retain the file for at least two years following the date of such measurements, maintenance reports, and records.  All reports are sent to the delegated state or local authority.   In the event that there is no such delegated authority, the reports are sent directly to the U.S. Environmental Protection Agency (EPA) regional office.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Based on information reported to the Agency under the Greenhouse Gas Reporting Program in calendar year 2012, we determined that there were 96 Portland cement plants (respondents) in the United States operating 136 cement kilns.  We assume that two plants per year will undergo modifications or reconstruction such that they will be subject to the initial notification reports and performance test requirement of the final NSPS.  This estimated number of reconstructed sources per year is based on our 2010 amendment estimating that 7 kilns will undergo reconstruction during a three-year period. 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The Office of Management and Budget (OMB) approved the currently active ICR without any "Terms of Clearance."
--------------------------------------------------------------------------------
      
	There are approximately 96 cement plants, all of which are owned and operated by the portland cement industry.  None of the plants in the United States are owned by either state, local, tribal, or the Federal government.  They are all owned and operated solely by private for-profit businesses.  The "burden" to the "Affected Public" may be found below in Table 1: Annual Respondent Burden and Cost  -  NSPS for Portland Cement Plants (40 CFR Part 60, Subpart F) (Renewal).  The Federal Government "burden" is attributed entirely to work performed by either Federal employees or government contractors and may be found below in Table 2: Average Annual EPA Burden and Cost  -  NSPS for Portland Cement Plants (40 CFR Part 60, Subpart F) (Renewal). 

--------------------------------------------------------------------------------
2.  Need for and Use of the Collection
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      2(a)  Need/Authority for the Collection
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The EPA is charged under Section 111 of the Clean Air Act (CAA), as amended, to establish standards of performance for new stationary sources that reflect: 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            . . . application of the best technological system of continuous emissions reduction which (taking into consideration the cost of achieving such emissions reduction, or any non-air quality health and environmental impact and energy requirements) the Administrator determines has been adequately demonstrated.  Section 111(a)(l).
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
The Agency refers to this charge as selecting the best demonstrated technology (BDT).  Section 111 also requires that the Administrator review and, if appropriate, revise such standards every four years.  In addition, section 114(a) states that the Administrator may require any owner/operator subject to any requirement of this Act to: 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            (A) Establish and maintain such records; (B) make such reports; (C) install, use, and maintain such monitoring equipment, and use such audit procedures, or methods; (D) sample such emissions (in accordance with such procedures or methods, at such locations, at such intervals, during such periods, and in such manner as the Administrator shall prescribe); (E) keep records on control equipment parameters, production variables or other indirect data when direct monitoring of emissions is impractical; (F) submit compliance certifications in accordance with Section 114(a)(3); and (G) provide such other information as the Administrator may reasonably require.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      In the Administrator's judgment, NOx, SO2, and PM emissions from portland cement plants either cause or contribute to air pollution that may reasonably be anticipated to endanger public health and/or welfare.  Therefore, the NSPS were promulgated for this source category at 40 CFR Part 60, Subpart F.
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      2(b)  Practical Utility/Users of the Data
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The recordkeeping and reporting requirements in the standard ensure compliance with the applicable regulations which where promulgated in accordance with the Clean Air Act.  The collected information is also used for targeting inspections and as evidence in legal proceedings.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Performance tests are required in order to determine an affected facility's initial capability to comply with the emission standard. Continuous emission monitors are used to ensure compliance with the standard at all times. During the performance test a record of the operating parameters under which compliance was achieved may be recorded and used to determine compliance in place of a continuous emission monitor.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The notifications required in the standard are used to inform the Agency or delegated authority when a source becomes subject to the requirements of the regulations.  The reviewing authority may then inspect the source to check if the pollution control devices are properly installed and operated, leaks are being detected and repaired, and the standard are being met.  The performance test may also be observed.
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      The required semiannual reports are used to determine periods of excess emissions, identify problems at the facility, verify operation/maintenance procedures and for compliance determinations.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
3.  Non-duplication, Consultations, and Other Collection Criteria
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The requested recordkeeping and reporting are required under 40 CFR Part 60, Subpart F.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      3(a)  Non-duplication
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
       If the subject standards have not been delegated, the information is sent directly to the appropriate EPA regional office.  Otherwise, the information is sent directly to the delegated state or local agency.  If either a state or local agency has adopted its own similar standards to implement the Federal standards, a copy of the report submitted to the state or local agency can be sent to the Administrator in lieu of the report required by the Federal standards.  Therefore,  duplication does not exist.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      3(b)  Public Notice Required Prior to ICR Submission to OMB
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      An announcement of a public comment period for the renewal of this ICR was published in the Federal Register (78 FR 35023) on June 11, 2013.  No comments were received on the burden published in the Federal Register. 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      3(c)  Consultations
      
--------------------------------------------------------------------------------
      The Agency's industry experts have been consulted, and the Agency's internal data sources and projections of industry growth over the next three years have been considered.  The primary source of information as reported by industry, in compliance with the recordkeeping and reporting provisions in the standard, is the Online Tracking Information System (OTIS) which is operated and maintained by EPA's Office of Compliance.  OTIS is EPA's database for the collection, maintenance, and retrieval of all compliance data.  The growth rate for the industry is based on our consultations with the Agency's internal industry experts. 

      Industry trade associations and other interested parties were provided an opportunity to comment on the burden associated with the standard as it was being developed and the standard has been previously reviewed to determine the minimum information needed for compliance purposes.  In developing this ICR, we contacted both the Portland Cement Association, at (202) 408-9494, and the Concrete Foundation Association, at (319) 895-6940.

      It is our policy to respond after a thorough review of comments received since the last ICR renewal as well as those submitted in response to the first Federal Register notice.  In this case, no comments were received.
      
--------------------------------------------------------------------------------
      3(d)  Effects of Less Frequent Collection
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Less frequent information collection would decrease the margin of assurance that facilities are continuing to meet the standards.  Requirements for information gathering and recordkeeping are useful techniques to ensure that good operation and maintenance practices are applied and emission limitations are met.  If the information required by these standards was collected less frequently, the proper operation and maintenance of control equipment and the possibility of detecting violations would be less likely.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      3(e)  General Guidelines
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      These reporting or recordkeeping requirements do not violate any of the regulations promulgated by OMB under 5 CFR part 1320, section 1320.5.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      3(f)  Confidentiality
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Any information submitted to the Agency for which a claim of confidentiality is made will be safeguarded according to the Agency policies set forth in Title 40, chapter 1, part 2, subpart B - Confidentiality of Business Information (CBI) (see 40 CFR 2; 41 FR 36902, September 1, 1976; amended by 43 FR 40000, September 8, 1978; 43 FR 42251, September 20, 1978; 44 FR 17674, March 23, 1979).
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      3(g)  Sensitive Questions
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The reporting or recordkeeping requirements in these standards do not include sensitive questions.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
4.  The Respondents and the Information Requested
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      4(a)  Respondents/SIC Codes
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The respondents to the recordkeeping and reporting requirements are Portland cement plants.  The United States Standard Industrial Classification (SIC) code for the respondents affected by the standards is SIC code 3241 which corresponds to the North American Industry Classification System (NAICS) code 327310 for Cement Manufacturing.  
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      4(b)  Information Requested 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            (i)  Data Items
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      In this ICR, all the data that is recorded or reported is required by the NSPS for Portland Cement Plants (40 CFR Part 60, Subpart F).  
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      A source must make the following reports:
--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Notifications
--------------------------------------------------------------------------------
Notification of construction/reconstruction
--------------------------------------------------------------------------------
60.7(a)(1)
--------------------------------------------------------------------------------
Notification of anticipated startup
--------------------------------------------------------------------------------
60.7(a)(2)
--------------------------------------------------------------------------------
Notification of actual startup
--------------------------------------------------------------------------------
60.7(a)(3)
--------------------------------------------------------------------------------
Notification of physical or operational change which may increase the emission rate
--------------------------------------------------------------------------------
60.7(a)(4)
--------------------------------------------------------------------------------
Notification of demonstration of continuous monitoring system
--------------------------------------------------------------------------------
60.7(a)(5)
--------------------------------------------------------------------------------
Notification of initial performance tests notice
--------------------------------------------------------------------------------
60.8(d)
--------------------------------------------------------------------------------
Notification of initial performance test results
--------------------------------------------------------------------------------
60.8(a)
--------------------------------------------------------------------------------
Repeat performance test results
--------------------------------------------------------------------------------
60.64
--------------------------------------------------------------------------------
Semiannual malfunction report
--------------------------------------------------------------------------------
60.7(b), 60.65(c)
--------------------------------------------------------------------------------
Semiannual report on excess emissions
--------------------------------------------------------------------------------
60.7(c), 60.65(a-b)
--------------------------------------------------------------------------------
Site-specific monitoring plan for bag leak detectors
--------------------------------------------------------------------------------
60.63(f)(2)
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      A source must keep the following records:
--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Recordkeeping
--------------------------------------------------------------------------------
Startup, shutdown, malfunctions, periods where the continuous monitoring system is inoperative 
--------------------------------------------------------------------------------
60.7(b), 60.65(c)
--------------------------------------------------------------------------------
Records of ongoing monitoring
--------------------------------------------------------------------------------
60.7(f)
--------------------------------------------------------------------------------
Record daily production and kiln feed rates
--------------------------------------------------------------------------------
60.63(a)
--------------------------------------------------------------------------------
Records of exceedance
--------------------------------------------------------------------------------
60.65(a-b)
--------------------------------------------------------------------------------
Maintain all records for two years
--------------------------------------------------------------------------------
60.7(f)
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
Electronic Reporting
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Some of the respondents are using monitoring equipment that automatically records parameter data.  Although personnel at the affected facility must still evaluate the data, internal automation has significantly reduced the burden associated with monitoring and recordkeeping at a plant site. 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Also, regulatory agencies in cooperation with the respondents continue to create reporting systems to transmit data electronically.  However, electronic reporting systems are still not widely used.  At this time, it is estimated that approximately 10 percent of the respondents use electronic reporting.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            (ii)  Respondent Activities	
--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Respondent Activities

--------------------------------------------------------------------------------
Read instructions.

--------------------------------------------------------------------------------
Install, calibrate, maintain, and operate SO2 and NOx Continuous Emission Monitoring Systems (CEMS), flow meters, and PM continuous parametric monitoring system (CPMS). 

--------------------------------------------------------------------------------
Perform initial performance test, Reference Method 5 or 5l test, and repeat performance tests if necessary.

--------------------------------------------------------------------------------
Write the notifications and reports listed above.

--------------------------------------------------------------------------------
Enter information required to be recorded above.

--------------------------------------------------------------------------------
Submit the required reports developing, acquiring, installing, and utilizing technology and systems for the purpose of collecting, validating, and verifying information.

--------------------------------------------------------------------------------
Develop, acquire, install, and utilize technology and systems for the purpose of processing and maintaining information.

--------------------------------------------------------------------------------
Develop, acquire, install, and utilize technology and systems for the purpose of disclosing and providing information.

--------------------------------------------------------------------------------
Train personnel to be able to respond to a collection of information.

--------------------------------------------------------------------------------
Transmit, or otherwise disclose the information.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Currently sources are using monitoring and reporting equipment that provide parameter data in an automated way e.g., continuous parameter monitoring system.  Although personnel at the source still need to evaluate the data, this type of monitoring equipment has significantly reduced the burden associated with monitoring and recordkeeping. 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
5.  The Information Collected:  Agency Activities, Collection Methodology, and Information Management
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      5(a)  Agency Activities  
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      EPA conducts the following activities in connection with the acquisition, analysis, storage, and distribution of the required information.
--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Agency Activities

--------------------------------------------------------------------------------
Review notifications and reports, including performance test reports, and excess emissions reports, required to be submitted by industry.

--------------------------------------------------------------------------------
Audit facility records.

--------------------------------------------------------------------------------
Input, analyze, and maintain data in the Online Tracking Information System (OTIS). 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      5(b)  Collection Methodology and Management
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Following notification of startup, the reviewing authority could inspect the source to determine whether the pollution control devices are properly installed and operated.  Performance test reports are used by the Agency to discern a source's initial capability to comply with the emission standard, and note the operating conditions under which compliance was achieved.  Data and records maintained by the respondents are tabulated and published for use in compliance and enforcement programs.  The semiannual reports are used for problem identification, as a check on source operation and maintenance, and for compliance determinations.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Information contained in the reports is entered into OTIS which is operated and maintained by EPA's Office of Compliance.  OTIS is EPA's database for the collection, maintenance, and retrieval of compliance data for approximately 125,000 industrial and government-owned facilities.  EPA uses the OTIS for tracking air pollution compliance and enforcement by local and state regulatory agencies, EPA regional offices and EPA headquarters.  EPA and its delegated Authorities can edit, store, retrieve and analyze the data.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
       The records required by this regulation must be retained by the owner/operator for two years.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      5(c)  Small Entity Flexibility
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      A majority of the respondents are large entities (i.e., large businesses).  However, the impact on small entities (i.e., small businesses) was taken into consideration during the development of the regulation.  Due to technical considerations involving the process operations and the types of control equipment employed, the recordkeeping and reporting requirements are the same for both small and large entities.  The Agency considers these to be the minimum requirements needed to ensure compliance and, therefore, cannot reduce them further for small entities.  To the extent that larger businesses can use economies of scale to reduce their burden, the overall burden will be reduced.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      5(d)  Collection Schedule
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The specific frequency for each information collection activity within this request is shown below in Table 1: Annual Respondent Burden and Cost  -  NSPS for Portland Cement Plants (40 CFR Part 60, Subpart F) (Renewal). 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
6.  Estimating the Burden and Cost of the Collection
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Table 1 documents the computation of individual burdens for the recordkeeping and reporting requirements applicable to the industry for the subpart included in this ICR.  The individual burdens are expressed under standardized headings believed to be consistent with the concept of burden under the Paperwork Reduction Act.  Where appropriate, specific tasks and major assumptions have been identified.  Responses to this information collection are mandatory.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The Agency may not conduct or sponsor, and a person is not required to respond to, a collection of information unless it displays a currently valid OMB Control Number.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      6(a)  Estimating Respondent Burden
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The average annual burden to industry over the next three years from these recordkeeping and reporting requirements is estimated to be 14,535 (Total Labor Hours from Table 1 below).   These hours are based on Agency studies and background documents from the development of the regulation, Agency knowledge and experience with the NSPS program, the previously- approved ICR, and any comments received.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      6(b)  Estimating Respondent Costs
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            (i)  Estimating Labor Costs 
--------------------------------------------------------------------------------
 
--------------------------------------------------------------------------------
      This ICR uses the following labor rates: 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            Managerial	$123.04 ($58.59+ 110%)   
--------------------------------------------------------------------------------
            Technical	$101.22 ($48.20 + 110%)
--------------------------------------------------------------------------------
            Clerical	$51.18 ($24.37 + 110%)
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
These rates are from the United States Department of Labor, Bureau of Labor Statistics, March 2013, "Table 2. Civilian Workers, by occupational and industry group."  The rates are from column 1, "Total compensation."  The rates have been increased by 110 percent to account for the benefit packages available to those employed by private industry.
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            (ii)  Estimating Capital/Startup and Operation and Maintenance Costs
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      The type of industry costs associated with the information collection activities in the subject standard are both labor costs which are addressed elsewhere in this ICR and the costs associated with continuous monitoring.  The capital/startup costs are one time costs when a facility becomes subject to the regulation.  The annual operation and maintenance costs are the ongoing costs to maintain the monitor and other costs such as photocopying and postage.
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
            (iii)  Capital/Startup vs. Operation and Maintenance (O&M) Costs
--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Capital/Startup vs. Operation and Maintenance (O&M) Costs

--------------------------------------------------------------------------------
(A)
--------------------------------------------------------------------------------
Continuous Monitoring Device

--------------------------------------------------------------------------------
(B)
--------------------------------------------------------------------------------
Capital/Startup Cost for One Respondent

--------------------------------------------------------------------------------
(C)
--------------------------------------------------------------------------------
Number of New Respondents 

--------------------------------------------------------------------------------
(D)
--------------------------------------------------------------------------------
Total Capital/Startup Cost,  (B X C)

--------------------------------------------------------------------------------
(E)
--------------------------------------------------------------------------------
Annual O&M Costs for One Respondent

--------------------------------------------------------------------------------
(F)
--------------------------------------------------------------------------------
Number of Respondents  with O&M

--------------------------------------------------------------------------------
(G)
--------------------------------------------------------------------------------
Total O&M,
--------------------------------------------------------------------------------
(E X F)
--------------------------------------------------------------------------------
CEMS
--------------------------------------------------------------------------------
$19,507
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
$39,014
--------------------------------------------------------------------------------
$7,490
--------------------------------------------------------------------------------
96
--------------------------------------------------------------------------------
$719,040
--------------------------------------------------------------------------------
Flow Meter
--------------------------------------------------------------------------------
$8,090
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
$16,180
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------

--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
Total
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
$55,194
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
$719,040
--------------------------------------------------------------------------------
 	
--------------------------------------------------------------------------------
      The total capital/startup costs for this ICR are $55,194.  This is the total of column D in the above table. 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The total operation and maintenance (O&M) costs for this ICR are $719,040.  This is the total of column G. 
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      The average annual cost for capital/startup and operation and maintenance costs to industry over the next three years of the ICR is estimated to be $774,234.   
--------------------------------------------------------------------------------
      6(c)  Estimating Agency Burden and Cost
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The only costs to the Agency are those costs associated with analysis of the reported information.  EPA's overall compliance and enforcement program includes such activities as the examination of records maintained by the respondents, periodic inspection of sources of emissions, and the publication and distribution of collected information. 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The average annual Agency cost during the three years of the ICR is estimated to be $41,325.  
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      This cost is based on the average hourly labor rate as follows:

		Managerial	$62.27 (GS-13, Step 5, $38.92 + 60%) 
		Technical	$46.21 (GS-12, Step 1, $28.88 + 60%)
		Clerical	$25.01 (GS-6, Step 3, $15.63 + 60%)
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
These rates are from the Office of Personnel Management (OPM), 2013 General Schedule, which excludes locality rates of pay.  The rates have been increased by 60 percent to account for the benefit packages available to government employees.  Details upon which this estimate is based appear below in Table 2: Average Annual EPA Burden and Cost  -  NSPS for Portland Cement Plants (40 CFR Part 60, Subpart F) (Renewal).
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      6(d)  Estimating the Respondent Universe and Total Burden and Costs
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      Based on our research for this ICR, on average over the next three years, approximately 96 existing respondents will be subject to these standards.  It is estimated that no additional respondents per year will become subject.  However, two existing respondents per year will undergo reconstruction.  The overall average number of respondents, as shown in the table below, is 96 per year. 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The number of respondents is calculated using the following table that addresses the three years covered by this ICR.  
--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Number of Respondents

--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Respondents That Submit Reports

--------------------------------------------------------------------------------
Respondents That Do Not Submit Any Reports

--------------------------------------------------------------------------------

                                       
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
Year
                                       
--------------------------------------------------------------------------------
(A)
--------------------------------------------------------------------------------
Number of New Respondents [1]
                                       
--------------------------------------------------------------------------------
(B)
--------------------------------------------------------------------------------
Number of Existing Respondents
                                       
--------------------------------------------------------------------------------
(C)
--------------------------------------------------------------------------------
Number of Existing  Respondents that keep records but do not submit reports
                                       
--------------------------------------------------------------------------------
(D)
--------------------------------------------------------------------------------
Number of Existing Respondents That Are Also New Respondents
                                       
--------------------------------------------------------------------------------
(E)
--------------------------------------------------------------------------------
Number of Respondents
--------------------------------------------------------------------------------
(E=A+B+C-D)

--------------------------------------------------------------------------------
1
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
96
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
96

--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
96
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
96

--------------------------------------------------------------------------------
3
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
96
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
96
--------------------------------------------------------------------------------
Average
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
96
--------------------------------------------------------------------------------
0
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
96
--------------------------------------------------------------------------------
      [1] New respondents include sources with constructed, reconstructed and modified affected facilities.  
--------------------------------------------------------------------------------
                                                
--------------------------------------------------------------------------------
      Column D is subtracted to avoid double-counting respondents.  As shown above, the average Number of Respondents over the three year period of this ICR is 96. 
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      The total number of annual responses per year is calculated using the following table: 
--------------------------------------------------------------------------------


--------------------------------------------------------------------------------
Total Annual Responses
                                       
--------------------------------------------------------------------------------
(A)
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
Information Collection Activity
                                       
--------------------------------------------------------------------------------
(B)
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
Number of Respondents
                                       
--------------------------------------------------------------------------------
(C)
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
Number of Responses
                                       
--------------------------------------------------------------------------------
(D)
--------------------------------------------------------------------------------
Number of Existing Respondents That Keep Records But Do Not Submit Reports
                                       
--------------------------------------------------------------------------------
(E)
--------------------------------------------------------------------------------
Total Annual  Responses
--------------------------------------------------------------------------------
E=(BxC)+D
--------------------------------------------------------------------------------
Notification of construction/ reconstruction
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
1
--------------------------------------------------------------------------------
N/A
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
Notification of actual startup
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
1
--------------------------------------------------------------------------------
N/A
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
Notification of physical or operational change
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
1
--------------------------------------------------------------------------------
N/A
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
Notification of demonstration of CEMS
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
1
--------------------------------------------------------------------------------
N/A
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
Notification of initial performance tests
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
1
--------------------------------------------------------------------------------
N/A
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
Report of performance test
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
1
--------------------------------------------------------------------------------
N/A
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
Semiannual report
--------------------------------------------------------------------------------
96
--------------------------------------------------------------------------------
2
--------------------------------------------------------------------------------
N/A
--------------------------------------------------------------------------------
192
--------------------------------------------------------------------------------
Total Number of Annual Responses
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------

--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
204
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The number of Total Annual Responses is 204.  
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      The total annual labor costs are $1,421,761.  Details regarding these estimates may be found below in Table 1: Annual Respondent Burden and Cost  -  NSPS for Portland Cement Plants (40 CFR Part 60, Subpart F) (Renewal). 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      6(e)  Bottom Line Burden Hours and Cost Tables
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The detailed bottom line burden hours and cost calculations for the respondents and the Agency are shown in Tables 1 and 2, respectively, and summarized below.  
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
            (i) Respondent Tally
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The total annual labor hours are 14,535.  Details regarding these estimates may be found below in Table 1:  Annual Respondent Burden and Cost  -  NSPS for Portland Cement Plants (40 CFR Part 60, Subpart F) (Renewal).
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      Furthermore, the annual public reporting and recordkeeping burden for this collection of information is estimated to average 71 hours per response.
--------------------------------------------------------------------------------
      
--------------------------------------------------------------------------------
      The total annual capital/startup and O&M costs to the regulated entity are $774,234.  The cost calculations are detailed in Section 6(b)(iii), Capital/Startup vs. Operation and Maintenance (O&M) Costs.
--------------------------------------------------------------------------------
                  
--------------------------------------------------------------------------------
            (ii) The Agency Tally
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The average annual Agency burden and cost over next three years is estimated to be 917 labor hours at a cost of $41,325.  See below Table 2: Average Annual EPA Burden and Cost  -  NSPS for Portland Cement Plants (40 CFR Part 60, Subpart F) (Renewal).
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      6(f)  Reasons for Change in Burden
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      There is an adjustment decrease in the respondent and Agency burden.  This is not due to any program changes.  The decrease occurred because we have modified the number of existing cement plants from 118 to 96 to reflect the latest industry data collected by the Agency's Greenhouse Gas Reporting Program.  This revision provides a more accurate estimate for the Portland cement sector, and results in an overall decrease in burden estimate. 
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      6(g)  Burden Statement
--------------------------------------------------------------------------------

--------------------------------------------------------------------------------
      The annual public reporting and recordkeeping burden for this collection of information is estimated to average 71 hours per response.  "Burden" means the total time, effort, or financial resources expended by persons to generate, maintain, retain, or disclose or provide information to or for a Federal agency.  This includes the time needed to review instructions; develop, acquire, install, and utilize technology and systems for the purposes of collecting, validating, and verifying information, processing and maintaining information, and disclosing and providing information; adjust the existing ways to comply with any previously applicable instructions and requirements; train personnel to be able to respond to a collection of information; search data sources; complete and review the collection of information; and transmit or otherwise disclose the information.
--------------------------------------------------------------------------------
      An agency may not conduct or sponsor, and a person is not required to respond to, a collection of information unless it displays a valid OMB Control Number.  The OMB Control Numbers for EPA regulations are listed at 40 CFR part 9 and 48 CFR chapter 15.

	To comment on the Agency's need for this information, the accuracy of the provided burden estimates, and any suggested methods for minimizing respondent burden, including the use of automated collection techniques, EPA has established a public docket for this ICR under Docket ID Number EPA-HQ-OECA-2013-0327.  An electronic version of the public docket is available at http://www.regulations.gov/, which may be used to obtain a copy of the draft collection of information, submit or view public comments, access the index listing of the contents of the docket, and to access those documents in the public docket that are available electronically.  When in the system, select "search," then key in the docket ID number identified in this document.  The documents are also available for public viewing at the Enforcement and Compliance Docket and Information Center in the EPA Docket Center (EPA/DC), WJC West, Room 3334, 1301 Constitution Ave., NW, Washington, DC.  The EPA Docket Center Public Reading Room is open from 8:30 a.m. to 4:30 p.m., Monday through Friday, excluding legal holidays.  The telephone number for the Reading Room is (202) 566-1744, and the telephone number for the docket center is (202) 566-1744.  Also, you can send comments to the Office of Information and Regulatory Affairs, Office of Management and Budget, 725 17th Street, NW, Washington, DC 20503, Attention: Desk Officer for EPA.  Please include the EPA Docket ID Number EPA-HQ-OECA-2013-0327 and OMB Control Number 2060-0025 in any correspondence. 

Part B of the Supporting Statement

This part is not applicable because no statistical methods were used in collecting this information.

Table 1: Annual Respondent Burden and Cost  -  NSPS for Portland Cement Plants (40 CFR Part 60, Subpart F) (Renewal)

                                  Burden item
                                     (A) 
                          Person hours per occurrence
                                     (B) 
                  No. of occurrences per respondent per year
                                     (C) 
                  Person hours per respondent per year (AxB)
                          (D) Respondent per year [a]
                  (E) Technical person- hours per year (CxD)
                (F) Management person/ hours per year (Ex0.05)
                  (G) Clerical person hours per year (Ex0.1)
                                     (H) 
                            Total Cost per year [b]
1.  Applications
                                      N/A
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
2.  Surveys and studies
                                      N/A
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
3. Reporting requirements
                                       
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
    A.  Read instructions [c]
                                       1
                                       1
                                       1
                                       2
                                       2
                                      0.1
                                      0.2
                                                                       $224.98 
    B.  Required activities 
                                       
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
          Initial performance test [d]
                                      36
                                       1
                                      36
                                       2
                                      72
                                      3.6
                                      7.2
                                                                     $8,099.28 
          Repeat performance test [e]
                                      36
                                       1
                                      36
                                       1
                                      36
                                      1.8
                                      3.6
                                                                     $4,049.64 
          CEMS initial performance test [f]
                                       8
                                       1
                                       8
                                       2
                                      16
                                      0.8
                                      1.6
                                                                     $1,799.84 
          CEMS monitoring
                                      0.5
                                       1
                                      0.5
                                       2
                                       1
                                     0.05
                                      0.1
                                                                       $112.49 
          CEMS quarterly inspections [g]
                                       2
                                       4
                                       8
                                       2
                                      16
                                      0.8
                                      1.6
                                                                     $1,799.84 
          CEMS daily calibration drift tests [h]
                                      0.3
                                      330
                                      99
                                       2
                                      198
                                      9.9
                                     19.8
                                                                    $22,273.02 
          Daily monitoring (CEMS) [i]
                                      0.5
                                      330
                                      165
                                       2
                                      330
                                     16.5
                                      33
                                                                    $37,121.70 
   C.   Create information 
                                    See 3B
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
   D.   Gather existing information
                                    See 3E
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
   E.   Write report 
                                       
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
        Notification of construction/reconstruction 
                                       2
                                       1
                                       2
                                       2
                                       4
                                      0.2
                                      0.4
                                                                       $449.96 
        Notification of actual startup 
                                       2
                                       1
                                       2
                                       2
                                       4
                                      0.2
                                      0.4
                                                                       $449.96 
        Notification of physical or operational change 
                                       2
                                       1
                                       2
                                       2
                                       4
                                      0.2
                                      0.4
                                                                       $449.96 
        Notification of demonstration of CMS
                                       2
                                       1
                                       2
                                       2
                                       4
                                      0.2
                                      0.4
                                                                       $449.96 
        Report of performance test 
                                    See 3B
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
        Notification of initial performance test 
                                       2
                                       1
                                       2
                                       2
                                       4
                                      0.2
                                      0.4
                                                                       $449.96 
        Report of performance test
                                       2
                                       1
                                       2
                                       2
                                       4
                                      0.2
                                      0.4
                                                                       $449.96 
        Semiannual reports [j]
                                      24
                                       2
                                      48
                                      96
                                     4,608
                                     230.4
                                     460.8
                                                                   $518,353.92 
Subtotal  for Reporting  Requirements
                                       
                                       
                                       
                                       
                                    6,098.5
                                                                    $596,534.47
4.  Recordkeeping requirements
                                       
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
   A.  Read instructions 
                                    See 3A
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
   B.   Plan activities 
                                  See 3B    
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
   C.   Implement activities
                                    See 3B
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
   D.  Develop record system 
                                      N/A
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
   E.  Time to enter information
                                       
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
     Daily production and kiln feed rates [k]
                                     0.125
                                      330
                                     41.25
                                      96
                                     3,960
                                      198
                                      396
                                                                   $445,460.40 
     Data Collection [l]
                                      0.1
                                      330
                                      33
                                      96
                                     3,168
                                     158.4
                                     316.8
                                                                   $356,368.32 
     Records of startup, shutdown malfunction [m]
                                      1.5
                                       1
                                      1.5
                                      96
                                      144
                                      7.2
                                     14.4
                                                                    $16,198.56 
   F.  Train personnel for CEMS maintenance [n]
                                      16
                                       2
                                      32
                                       2
                                      64
                                      3.2
                                      6.4
                                                                     $7,199.36 
  G.   Audits
                                      16
                                       1
                                      16
                                       0
                                       0
                                       0
                                       0
                                                                         $0.00 
Subtotal  for Recordkeeping Requirements  
                                       
                                       
                                       
                                       
                                    8,436.4
                                                                    $825,226.64
TOTAL LABOR BURDEN AND COST (rounded)
 
 
 
 
                                    14,535
                                                                    $1,421,761 

Assumptions:
[a]  We have assumed that the average number of respondents that will be subject to the rule will be 96 existing plants, operating 136 kilns.  There will be no additional sources over the three-year period of this ICR.  We assume that two existing plants will undergo modification or reconstruction which will require re-submittal or notifications and retesting.
[b]  This ICR uses the following labor rates:  $123.04 per hour for Executive, Administrative, and Managerial labor; $101.22 per hour for Technical labor, and $51.18 per hour for Clerical labor.  These rates are from the United States Department of Labor, Bureau of Labor Statistics, March, 2013, Table 2. Civilian Workers, by Occupational and Industry group.  The rates are from column 1, Total Compensation.  The rates have been increased by 110 percent to account for the benefit packages available to those employed by private industry.
[c]  We have assumed that it will take one hour for each respondent to read instructions.
[d]  We have assumed that each respondent will take 36 hours to perform initial performance tests.
[e]  We have assumed that one respondent will have to repeat initial performance tests.. 
[f]  We have assumed that it will take each respondent eight hours four times per year to perform CEMS inspections.
g  We have assumed that it will take each respondent 2 hours 4 times per year to record daily production and kiln feed rates.
[h]  We have assumed that it will take each respondent 0.3 hours 330 times per year to perform daily calibration drift tests.
[i]  We have assumed that it will take each respondent 0.5 hours 330 times per year to perform daily CEMS monitoring.
[j]  We have assumed that it will take each respondent 24 hours two times per year to prepare semiannual reports.
[k]  We have assumed that it will take each respondent 0.125 hours 330 times per year to enter daily production and kiln feed rates information.
[l]  We have assumed that it will take each respondent 0.1 hours 330 times per year to enter data collection information.
[m]  We have assumed that it will take each respondent 1.5 hours once per year to record SSM.
[n]  We have assumed that it will take each respondent 16 hours twice a year to train personnel on how to maintain the CEMS.
Table 2: Average Annual EPA Burden and Cost  -  NSPS for Portland Cement Plants (40 CFR Part 60, Subpart F) (Renewal)

                                   Activity
                                     (A) 
                       EPA person- hours per occurrence
                                     (B) 
                     No. of occurrences per plant per year
                                     (C) 
                     EPA person- hours per plant per year 
                                     (AxB)
                                     (D) 
                             Plants per year  [a]
                                     (E) 
                       Technical person- hours per year 
                                     (CxD)
                 (F) Management person-hours per year (Ex0.05)
                                     (G) 
                        Clerical person-hours per year 
                                    (Ex0.1)
                                     (H) 
                                  Cost, $ [b]
Report review
                                       
                                       
                                       
                                       
                                       
                                       
                                       
                                                                              
   Notification of construction/reconstruction [c]
                                       2
                                       1
                                       2
                                       2
                                       4
                                      0.2
                                      0.4
                                                                       $207.30 
   Notification of actual startup [c, d]
                                      0.5
                                       1
                                      0.5
                                       2
                                       1
                                     0.05
                                      0.1
                                                                        $51.82 
   Notification of physical and operational change [c]
                                       2
                                       1
                                       2
                                       2
                                       4
                                      0.2
                                      0.4
                                                                       $207.30 
   Notification of initial performance test [c, e]
                                      0.5
                                      1.2
                                      0.6
                                       2
                                      1.2
                                     0.06
                                     0.12
                                                                        $62.19 
   Review test results [c, f]
                                       8
                                      1.2
                                      9.6
                                       2
                                     19.2
                                     0.96
                                     1.92
                                                                       $995.03 
   Review of semiannual reports [i]
                                       4
                                       2
                                       8
                                      96
                                      768
                                     38.4
                                     76.8
                                                                    $39,801.22 
TOTAL LABOR BURDEN AND COST (rounded)
 
 
 
 
                                      917
                                                                        $41,325

Assumptions:
[a]  We have assumed that the average number of respondents that will be subject to the rule will be 96 existing plants with 136 operating kilns.  There will be no additional sources over the three-year period of this ICR.  We assume that two existing plants will undergo modification or reconstruction which will require re-submittal or notifications, and retesting.
[b]  This cost is based on the following labor rates which incorporates a 1.6 benefits multiplication factor to account for government overhead expenses: $62.27 Managerial rate (GS-13, Step 5, $38.92 x 1.6), $46.21 Technical rate (GS-12, Step 1, $28.88 x 1.6), and $25.01 Clerical rate (GS-6, Step 3, $15.63 x 1.6).  These rates are from the Office of Personnel Management (OPM) "2013 General Schedule", which excludes locality rates of pay.
[c]  We have assumed that the number of existing plants that undergo construction or reconstruction will be two.
[d]  We have assumed that it will take each respondent 0.5 hours to review the actual startup report.
[e]  We have assumed that it will take each respondent 0.5 hours to review initial performance test report.
[f]  We have assumed that it will take each respondent 8 hours to review performance test results.
[g]  We have assumed that it will take each respondent 4 hours two times per year to review semiannual reports.
 
